| Most common failures | No# failures |
|---|
| Brakes imbalanced across an axle | 12 |
| Rear brake binding | 12 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Windscreen wiper does not clear the windscreen effectively | 7 |
| Registration plate lamp issues | 6 |
| Brake hose excessively deteriorated | 5 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Headlamp aim out of alignment | 5 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Offside Headlamp not working on main beam |1.7.5a| | 4 |
| Horn not working |1.6.2a| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Rear Braking system leaking |3.6.A.1| | 2 |
| Steering box has a significant oil leak |2.2.D.2e| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Upper Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Windscreen washer not working | 2 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 2 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 2 |
| Offside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 2 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Rear brake application uneven | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
| Offside Rear Leaf spring to axle securing bolt insecure |2.4.B.7b| | 1 |
| Nearside Rear Brake cable locking device insecure |3.5.1l| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Headlamp aim aimed so that it dazzles other road users no pattern |1.8.A.1a| | 1 |
| Offside Front Headlamp aim aimed so that it dazzles other road users no pattern |1.8.A.1a| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded outer sill middle and front |5.2.6| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded outer sill at rear |2.4.A.3| | 1 |
| Nearside Suspension component mounting prescribed area is excessively corroded inner sill at front |2.4.A.3| | 1 |
| Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement both |2.4.B.2| | 1 |
| Fuel system component leaking carburettor |7.2.3| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner wheel arch |6.1.B.2| | 1 |
| Nearside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill front to rear |6.1.B.2| | 1 |
| Offside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill front to rear |6.1.B.2| | 1 |
| Exhaust has a major leak of exhaust gases back box |7.1.2| | 1 |
| Offside Front Inner Suspension component mounting prescribed area is excessively corroded cil |2.4.A.3| | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner/outter/ inner wheel arch |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner/outer sail |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings jacking point |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings windscreen area |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings windscreen area |6.1.B.2| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded leef spring mount |2.4.A.3| | 1 |
| Fuel pipe insecure |7.2.1| | 1 |
| Steering system fouling |2.2.D.2a| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Fuel hose insecure |7.2.1| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings SEVERE CORROSION O/S/F INNER SILL UNDER VEHICLE AT FRONT |6.1.B.2| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Direction indicator flashing less than 60 times a minute |1.4.A.2g| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
| Registration plate issues | 1 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Front Windscreen wiper not working (3.4 (a)) | 1 |
| Front Anti-roll bar pin or bush excessively worn x 4 bushes (5.3.4 (a) (i)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Integral body structure inadequately repaired such that structural rigidity is significantly reduced (6.1.1 (d) (i)) | 1 |
| Nearside Front Integral body structure inadequately repaired such that structural rigidity is significantly reduced (6.1.1 (d) (i)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired (6.2.2 (d) (ii)) | 1 |
| Offside Front Steering linkage insecure to the extent there is excessive movement at the mountings bush missing (2.1.3 (a) (ii)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Nearside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Horn control missing |1.6.1| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front brake caliper securing device loose |3.5.1j| | 1 |
| Offside Front Brake pipe kinked |3.6.B.2b| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Offside Rear rear brake excessively fluctuating |3.7.B.3| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Offside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Steering column movement between the shaft and steering wheel |2.1.2b| | 1 |
| Nearside Rear Shock absorber detached |2.7.2b| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Steering box insecure |2.2.B.1a| | 1 |
| Offside Rear rear brake grabbing severely |3.7.A.5b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Brake hose damaged | 1 |
| Offside Front Upper Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Outer Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Nearside Outer Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Nearside Rear Hydraulic brake cylinder leaking and braking performance affected (1.1.16 (b) (ii)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Front brake application uneven | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Intermediate drop arm insecure to the extent there is excessive movement at the mountings (2.1.3 (a) (ii)) | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid |1.1.16 |b| |i|| | 1 |