| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 11 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 9 |
| Registration plate lamp issues | 8 |
| Windscreen wiper does not clear the windscreen effectively | 6 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 4 |
| Brakes imbalanced across an axle | 4 |
| Rear parking brake recording little or no effort | 3 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 2 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 2 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 2 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Horn not working (7.7 (a)) | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Passengers seat insecure (6.2.6 (a) (ii)) | 1 |
| Nearside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Offside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Nearside Position lamp showing red light to the front (4.2.3 (a) (ii)) | 1 |
| Offside Position lamp showing red light to the front (4.2.3 (a) (ii)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Offside Rear reflector missing (4.8.2 (a) (ii)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Horn control missing |1.6.1| | 1 |
| Nearside Rear Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Outer Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Front Position lamp not working both (4.2.1 (a) (ii)) | 1 |
| Rear Position lamp not working both (4.2.1 (a) (ii)) | 1 |
| Brake performance not tested due to brake bind n/s/r (1.2.1 (g)) | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn radius arm to body bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension arm pin or bush excessively worn radius arm to body bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Outer Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting sill/ upper (6.2.2 (d) (i)) | 1 |
| Nearside Rear Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting floor (6.2.2 (d) (i)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear brake binding | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Offside Rear Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction (3.1 (a) (ii)) | 1 |
| Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 1 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Nearside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Outer Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Nearside Rear Trailing arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt split (2.1.3 (g) (ii)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt split (2.1.3 (g) (ii)) | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn trailing arm (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension arm pin or bush excessively worn trailing arm (5.3.4 (a) (i)) | 1 |
| Nearside Rear Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Offside Rear Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Nearside Front Upper Suspension arm ball joint likely to become detached split pin missing from securing nut (5.3.4 (a) (ii)) | 1 |
| Dipswitch does not operate immediately when selected on main beam (4.1.3 (b)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect aftermarket bulb fitted (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect aftermarket bulb fitted (4.1.2 (c)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt split in 2 (2.1.3 (g) (ii)) | 1 |
| Offside Front Coil spring fractured or broken broken (5.3.1 (b) (i)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn bushes worn/split (5.3.4 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases multiple blows through out system (6.1.2 (a)) | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced inner/outer sill/floor - holed/corroded (7.1.1 (a) (i)) | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt both sides (2.1.3 (g) (ii)) | 1 |
| Front Steering rack gaiter missing or no longer prevents the ingress of dirt both sides (2.1.3 (g) (ii)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear Suspension arm pin or bush excessively worn trailing arm bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Front Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Lower Suspension arm pin or bush likely to become detached inner (5.3.4 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn inner (5.3.4 (a) (i)) | 1 |
| Anti-lock braking system warning lamp does not illuminate (1.6 (a)) | 1 |
| Nearside Front Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill end (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill end (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i)) | 1 |
| Nearside Front Battery insecure |1.9.1| | 1 |
| Nearside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Exhaust catalytic converter obviously modified (8.2.1.1 (a)) | 1 |
| Rear Exhaust system not adequately supported hanger |7.1.1| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Brake pipe excessively corroded | 1 |
| Offside Rear Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage ball joint likely to become detached |5.3.4 |a| |ii|| | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Nearside Front Front position lamp|s| not working sidelight |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working sidelight |1.1.A.3b| | 1 |
| An item not tested |Manual| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |