| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 38 |
| Registration plate lamp issues | 17 |
| Headlamp aim out of alignment | 11 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 8 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 6 |
| Rear brake binding | 5 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 5 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 5 |
| Brakes imbalanced across an axle | 4 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 4 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 3 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 3 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Battery insecure |1.9.1| | 2 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 2 |
| Brake pipe excessively corroded | 2 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 2 |
| Offside Front Anti-roll bar linkage missing |2.4.G.1| | 2 |
| Offside Rear Anti-roll bar linkage fractured |2.4.G.1| | 2 |
| Offside Rear Anti-roll bar linkage insecure |2.4.G.1| | 2 |
| Driver`s airbag obviously defective |5.4.1| | 2 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 2 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Front brake excessively fluctuating | 2 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
| Rear brake application uneven | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 2 |
| Windscreen has damage | 2 |
| Registration plate issues | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Offside Front Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| An item not tested |Manual| | 1 |
| Nearside Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp has a product on the light source so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Nearside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength sill is damaged & corroded end off sill is holed (5.3.6 (a) (i)) | 1 |
| Offside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength sill is damaged/ corroded & holed at end (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner /outer sill & sill end (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner /outer sill & sill end (5.3.6 (a) (i)) | 1 |
| Nearside Rear Upper Suspension component attachment bracket/mounting corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Rear Upper Suspension component attachment bracket/mounting corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Suspension arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Suspension arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Brake pedal anti-slip provision loose (1.1.2 (c)) | 1 |
| Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Front Anti-roll bar insecure |2.4.G.1| | 1 |
| Offside Front Anti-roll bar insecure |2.4.G.1| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Rear Exhaust silencer insecure |8.1.1 |b| |i|| | 1 |
| Offside Rear Anti-roll bar linkage damaged and seriously weakened not connected |2.4.G.1| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside rear parking |secondary| brake grabbing severely |3.7.B.6b| | 1 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Gas suspension unit totally deflated |2.4.D.1a| | 1 |
| Offside Front Gas suspension unit totally deflated |2.4.D.1a| | 1 |
| Nearside Front Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect image out put low (4.1.2 (c)) | 1 |
| Offside Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Nearside Front Position lamp not working bulb replaced (4.2.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working bulb replaced (4.2.1 (a) (ii)) | 1 |
| Offside Front Anti-roll bar linkage severely distorted |2.4.G.1| | 1 |
| Offside Rear Anti-roll bar linkage severely distorted |2.4.G.1| | 1 |
| Offside Front Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Lower Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Road wheel fixing loose one wheel nut missing |5.2.1 |a| |i|| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear brake caliper leaking |3.6.A.1| | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Drivers view of an obligatory external mirror significantly affected by an obstruction (3.1 (a) (ii)) | 1 |
| Offside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Headlamp aim not tested (4.1.2 (b)) | 1 |
| Nearside Headlamp aim so that beam "kick up" is not visible on the screen |1.8.B.1| | 1 |
| Nearside Front Seat belt webbing significantly weakened (7.1.2 (b) (ii)) | 1 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Bumper insecure (6.1.4 (a) (i)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn Front bush most (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn Front bush most (5.3.4 (a) (i)) | 1 |
| Offside All position lamps not working |1.1.A.3b| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Outer sill/lower wheel arch area. (5.3.6 (a) (i)) | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` wipers parking in centre of screen |8.3.1b| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Rear Body has a projection caused by damage Boot Light |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Obligatory mirror does not provide a view to the rear |8.1.2b| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded inner wheelarch |2.4.A.3| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Offside Front Service brake grabbing severely |1.2.1 |c|| | 1 |
| Rear Anti-roll bar has excessive play in a pin/bush Both |2.4.G.2| | 1 |
| Nearside Front Obligatory mirror insecure |8.1.1| | 1 |
| Nearside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Front Anti-roll bar severely distorted |2.4.G.1| | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear Inner Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp aim beam image obviously incorrect headlight tarnished, no pattern |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect headlight tarnished, no pattern |1.8.A.1b| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel stud|s| missing |4.2.A.1e| | 1 |