| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 20 |
| Headlamp aim out of alignment | 18 |
| Windscreen wiper does not clear the windscreen effectively | 11 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 5 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 4 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 3 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Offside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Brakes imbalanced across an axle | 2 |
| Offside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 2 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 2 |
| Nearside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
| Power steering pump leaking from a failed component RACK |2.3.3b| | 1 |
| Offside Rear brake caliper leaking |3.6.A.1| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Nearside Front Anti-roll bar linkage missing |2.4.G.1| | 1 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Lower Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |lamp damaged| |1.8.A.1b| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Registration plate issues | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Offside Front Torsion bar attachment bracket fractured |2.4.E.4b| | 1 |
| Stop lamp not working all of them |1.2.1b| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement rear anti roll bar d rubbers |2.4.G.2| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Rear Exhaust has a major leak of exhaust gases x2 places |7.1.2| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Headlamp aim not tested due to no pattern |4.1.2 |b|| | 1 |
| Oil leaking continuously from engine posing a serious risk to road safety |8.4.1 |a| |ii|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Emissions not tested due to oil leak |8.2.1.2 |d|| | 1 |
| Offside Front Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Upper Suspension arm locating pin locking device missing |2.4.G.3b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside rear brake excessively fluctuating |3.7.B.3| | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced Floor |7.1.1 |a| |i|| | 1 |
| Offside Rear Anti-roll bar ball joint excessively worn Link |5.3.4 |a| |i|| | 1 |
| Front Headlamp lens seriously defective (4.1.1 (b) (ii)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Headlamp light intensity severely reduced no pattern (4.1.4 (a)) | 1 |
| Offside Front Headlamp light intensity severely reduced no pattern (4.1.4 (a)) | 1 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Brake pedal anti-slip provision worn smooth |3.3.A.1b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Rear Stop lamp not working Offside & Nearside |1.2.1b| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Rear Anti-roll bar ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Rear Anti-roll bar linkage has excessive play in a pin/bush offside & nearside D bush`s |2.4.G.2| | 1 |
| Nearside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Windscreen wiper blade insecure | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Battery insecure |1.9.1| | 1 |
| Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Offside Front Track rod end ball joint worn to the extent there is a serious risk of detachment locking nut not tightened (2.1.3 (b) (ii)) | 1 |
| Nearside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Offside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Offside Headlamp cleaning device inoperative |1.7.2| | 1 |
| Nearside Headlamp levelling device inoperative |1.7.2| | 1 |
| Offside Headlamp levelling device inoperative |1.7.2| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Inner Suspension arm pin or bush excessively worn front bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Inner Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Exhaust system not adequately supported exhaust flexi broken |7.1.1| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Lower Suspension arm ball joint likely to become detached locking device missing. |5.3.4 |a| |ii|| | 1 |
| Offside Front Lower Suspension arm ball joint likely to become detached locking device missing. |5.3.4 |a| |ii|| | 1 |
| Nearside Rear Hydraulic brake calliper insecurely mounted |1.1.16 |c| |i|| | 1 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Central Rear Seat belt installation load spreading washer|s| missing from anchorage |10.1 |n|| | 1 |