Most common failures | No# failures |
---|
Headlamp aim out of alignment | 54 |
Brake pipe excessively corroded | 49 |
Windscreen wiper does not clear the windscreen effectively | 39 |
Parking brake: efficiency below requirements |3.7.B.7| | 29 |
Rear parking brake recording little or no effort | 19 |
Registration plate lamp issues | 15 |
Offside Stop lamp not working |1.2.1b| | 12 |
Registration plate issues | 11 |
Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 9 |
Brakes imbalanced across an axle | 8 |
Nearside Stop lamp not working |1.2.1b| | 8 |
Offside Front coil spring broken |2.4.C.1a| | 8 |
Nearside Front coil spring broken |2.4.C.1a| | 8 |
Parking brake lever has no reserve travel |3.1.6b| | 7 |
Anti-lock braking system warning lamp indicates an ABS fault | 7 |
Windscreen washer not working | 6 |
Front brake disc in such a condition that it is seriously weakened | 6 |
Service brake: efficiency below requirements |3.7.B.7| | 6 |
Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 6 |
Brake hose excessively deteriorated | 6 |
Rear brake binding | 5 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 5 |
Offside Front coil spring incomplete |2.4.C.1a| | 5 |
Offside Rear Stop lamp not working |1.2.1b| | 4 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 4 |
Electronic stability system warning lamp indicates a fault |3.4.1c| | 4 |
Nearside Front coil spring incomplete |2.4.C.1a| | 4 |
Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 4 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
Offside front brake binding |3.7.B.1| | 3 |
Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 3 |
Offside Headlamp cleaning device inoperative |1.7.2| | 3 |
Rear brake disc in such a condition that it is seriously weakened | 3 |
Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 3 |
Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
rear parking |secondary| brakes imbalanced | 2 |
Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
Nearside Front Service brake excessively binding (1.2.1 (f)) | 2 |
Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
Offside front brake juddering severely |3.7.A.2b| | 2 |
Nearside Front Service brake excessively binding |1.2.1 |f|| | 2 |
Offside Front Service brake excessively binding |1.2.1 |f|| | 2 |
Nearside Front front brake binding |3.7.B.1| | 2 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Rear Stop lamp not working |1.2.1b| | 2 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
Mechanical brake component has restricted free movement | 2 |
Nearside front brake binding |3.7.B.1| | 2 |
Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 2 |
Nearside Front coil spring fractured |2.4.C.1a| | 2 |
Offside Front coil spring fractured |2.4.C.1a| | 2 |
Rear fog lamp not working |1.3.2b| | 2 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
Brake performance not tested |3.7.A.1| | 2 |
Front brake application uneven | 2 |
Nearside Headlamp cleaning device inoperative |1.7.2| | 2 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
Offside Front Anti-roll bar insecure |2.4.G.1| | 2 |
Rear Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
Centre Power steering pipe|s| or hose|s| fouling other parts of the vehicle |2.3.2| | 1 |
Front Exhaust has a major leak of exhaust gases Flexi |7.1.2| | 1 |
Front Exhaust system insecure (6.1.2 (a)) | 1 |
Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
Central Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Nearside Front Front position lamp|s| insecure |1.1.A.3a| | 1 |
Nearside Lower Stop lamp not working |1.2.1b| | 1 |
Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Horn not working |1.6.2a| | 1 |
Nearside Front Brake hose connection leaking on a hydraulic braking system (1.1.12 (c) (ii)) | 1 |
Offside Front Brake hose connection leaking on a hydraulic braking system (1.1.12 (c) (ii)) | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen washer pipe loose and detached o/s front |3.5 |a|| | 1 |
Offside Rear Service brake grabbing severely |3.7.C.2| | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Nearside Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
front brake binding |3.7.B.1| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Offside Obligatory mirror does not provide a view to the rear |8.1.2b| | 1 |
Rear Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Rear Upper Trailing arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
Offside Rear Upper Trailing arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Nearside Rear Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
Nearside Rear Rear position lamp|s| has less than 50% of the light sources illuminating |1.1.A.3b| | 1 |
Offside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
Offside Obligatory mirror seriously obscured affecting the rear view |8.1.2a| | 1 |
Offside Steering arm deformed and unserviceable |2.2.C.1d| | 1 |
Offside Track rod end deformed and unserviceable |2.2.C.1d| | 1 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced dipped beam |1.7.5a| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Nearside Stop lamp(s) light intensity significantly reduced (4.3.3 (a) (ii)) | 1 |
Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Stop lamp(s) not working both (4.3.1 (a) (ii)) | 1 |
Rear brake application uneven | 1 |
Offside rear brakes release unevenly |3.7.B.4| | 1 |
Battery insecure |1.9.1| | 1 |
Fuel cap/sealing device missing |7.2.4a| | 1 |
Braking system leaking |3.6.A.1| | 1 |
Offside Front An item not tested |Manual| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Nearside Side repeater not working |1.4.A.2c| | 1 |
Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
Front front brakes release unevenly |3.7.B.4| | 1 |
Nearside Rear Anti-roll bar linkage insecure |2.4.G.1| | 1 |
Supplementary Restraint System warning lamp indicates a fault air bag |5.4.2| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
Brake performance not tested offside rear brake pipe burst during test |1.2.1 |g|| | 1 |
Offside Rear Outer Braking system leaking flexible to calliper |1.1.3 |d|| | 1 |
Nearside Front Anti-roll bar ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
Offside Front Obligatory mirror missing door mirror |8.1.1| | 1 |
Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Rear Rear position lamp|s| obscured more than 50% |1.1.A.3c| | 1 |
Offside Front Headlamp insecure |4.1.1 |c|| | 1 |
Offside Front Headlamp aim not tested |4.1.2 |b|| | 1 |
Front Undertray likely to become detached |6.2.1 |a| |ii|| | 1 |
Centre Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Offside Front Braking system leaking |3.6.A.1| | 1 |
Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
Nearside Rear Axle beam has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
Offside Rear Axle beam has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
brake disc in such a condition that it is seriously weakened |3.5.1i| | 1 |
Central Front Exhaust silencer likely to become detached (8.1.1 (b) (ii)) | 1 |
Offside Front Upper Anti-roll bar linkage fractured (5.3.3 (b) (ii)) | 1 |
Offside Front Exhaust has a major leak of exhaust gases Clamp on system ( securing bolt fractured ) (6.1.2 (a)) | 1 |
Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
Rear Axle beam has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
Windscreen wiper blade insecure | 1 |
Fuel cap/sealing device missing |6.1.3 |b| |i|| | 1 |
Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
Offside Front Hydraulic brake calliper inadequately mounted (1.1.16 (c) (i)) | 1 |
Offside Rear Hydraulic brake calliper inadequately mounted (1.1.16 (c) (i)) | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
Central Front Anti-roll bar ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
Nearside Headlamp levelling device obviously defective |1.7.2| | 1 |
Nearside Headlamp adversely affected by the operation of another lamp |1.7.5c| | 1 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Front Headlamp cleaning device inoperative |1.7.2| | 1 |
Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Front Anti-roll bar linkage missing |2.4.G.1| | 1 |
Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
Wheel nut|s| missing both rear |4.2.A.1e| | 1 |
Offside Rear Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside front brake juddering severely |3.7.A.2b| | 1 |
Wheel nut|s| missing o/s/r 1/5 |4.2.A.1e| | 1 |
Wheel nut|s| missing n/s/r 1/5 |4.2.A.1e| | 1 |
Nearside Front Wheel nut|s| missing 1/5 |4.2.A.1e| | 1 |
Offside Front Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 1 |
Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
Front Exhaust system insecure clamp bolt missing and the other bolt is about to disappear (6.1.2 (a)) | 1 |
Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Front brake excessively fluctuating | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Front Body has a sharp edge caused by damage coll damage |6.1.C.1| | 1 |
Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.5 |b| |i|| | 1 |
Electronic stability control warning lamp indicates a fault |7.12 |e|| | 1 |
Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
Offside Front Anti-roll bar linkage insecure |2.4.G.1| | 1 |
Centre Lower Power steering pipe|s| or hose|s| fouling other parts of the vehicle |2.3.2| | 1 |
Nearside Rear coil spring broken |2.4.C.1a| | 1 |
Nearside Front Anti-roll bar fractured |2.4.G.1| | 1 |
Fluid leak harmful to the environment or a risk to other road users fuel filter |8.4.1 |a| |i|| | 1 |
Headlamp cleaning device inoperative |1.7.2| | 1 |
Stop lamp remains on when the brakes are released | 1 |
Power steering pipe/hose leaking |2.1.5 |a|| | 1 |
Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
Offside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
Battery insecure plus terminals |1.9.1| | 1 |
Nearside Front Brake hose connection leaking on an air braking system joint to caliper (1.1.12 (c) (i)) | 1 |
Nearside Rear Brake load sensing valve linkage defective and function impaired |1.1.17 |a|| | 1 |
Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Anti-roll bar linkage has excessive play in a pin/bearing |2.4.G.2| | 1 |