Most common failures | No# failures |
---|
Headlamp aim out of alignment | 73 |
Registration plate lamp issues | 56 |
Parking brake: efficiency below requirements |3.7.B.7| | 51 |
Windscreen wiper does not clear the windscreen effectively | 49 |
Service brake: efficiency below requirements |3.7.B.7| | 41 |
Rear parking brake recording little or no effort | 29 |
Brake pipe excessively corroded | 28 |
Offside Rear fog lamp not working |1.3.2b| | 27 |
Brakes imbalanced across an axle | 25 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 23 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 22 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 22 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 20 |
Registration plate issues | 20 |
Horn not working |1.6.2a| | 17 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 16 |
Nearside Side repeater not working |1.4.A.2c| | 16 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 15 |
Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 14 |
Windscreen has damage | 14 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 13 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 12 |
Fuel system component leaking |7.2.3| | 12 |
Offside Side repeater not working |1.4.A.2c| | 11 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 11 |
Rear fog lamp tell tale not working |1.3.1b| | 11 |
Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 11 |
Exhaust has a major leak of exhaust gases |7.1.2| | 11 |
Fuel tank leaking |7.2.3| | 10 |
Offside rear brake recording little or no effort |3.7.B.5a| | 10 |
Offside Front position lamp|s| not working |1.1.A.3b| | 9 |
Rear brake binding | 9 |
Exhaust system not adequately supported |7.1.1| | 9 |
Nearside Stop lamp not working |1.2.1b| | 9 |
Offside Stop lamp not working |1.2.1b| | 9 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 8 |
Rear fog lamp switch faulty |1.3.1a| | 8 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 8 |
Offside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 8 |
Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 8 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 8 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 7 |
Brake hose excessively deteriorated | 7 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
Offside Front Side repeater not working |1.4.A.2c| | 7 |
Offside Rear Rear fog lamp not working |1.3.2b| | 7 |
Rear brake application uneven | 7 |
Nearside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 7 |
Emissions not tested |7.0| | 7 |
Rear Stop lamp not working |1.2.1b| | 6 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 6 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 6 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 6 |
Nearside Headlamp not working on main beam |1.7.5a| | 6 |
Direction indicators not working |1.4.A.2c| | 6 |
Rear Rear fog lamp not working |1.3.2b| | 6 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 6 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 6 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 6 |
Offside Headlamp not working on main beam |1.7.5a| | 6 |
Driver`s seat insecure |6.2.A.1| | 6 |
Nearside Front Side repeater not working |1.4.A.2c| | 6 |
Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 6 |
Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 6 |
Nearside Front Direction indicator not working |1.4.A.2c| | 6 |
Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 6 |
Steering system excessively tight |2.2.D.1| | 6 |
Nearside Obligatory mirror insecure |8.1.1| | 5 |
Front passenger seat insecure |6.2.3| | 5 |
Nearside Headlamp insecure |1.7.3| | 5 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 5 |
Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 5 |
Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 5 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 5 |
Offside Headlamp not working on dipped beam |1.7.5a| | 5 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 5 |
Offside Front Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 5 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
Battery insecure |1.9.1| | 5 |
Hazard warning switch faulty |1.4.B.1d| | 5 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 5 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 5 |
Front Drag link end ball joint has excessive play |2.2.B.1f| | 5 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 5 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 4 |
Offside Front brake disc excessively pitted |3.5.1h| | 4 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 4 |
Nearside front brake binding |3.7.B.1| | 4 |
Nearside Front Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 4 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 4 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 4 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 4 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 4 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 4 |
Nearside Rear rear brake grabbing severely |3.7.A.5b| | 4 |
Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 4 |
Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 4 |
Windscreen wiper blade insecure | 4 |
Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 4 |
Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 4 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 4 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 4 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Front Exhaust system not adequately supported |7.1.1| | 4 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
Steering system excessively rough |2.2.D.1| | 3 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 3 |
Offside Rear Direction indicator not working |1.4.A.2c| | 3 |
Nearside Rear Stop lamp not working |1.2.1b| | 3 |
Brake load sensing valve linkage seized |3.6.E.3| | 3 |
Offside Headlamp insecure |1.7.3| | 3 |
Offside Front Direction indicator not working |1.4.A.2c| | 3 |
Offside Front Driver`s seat insecure |6.2.A.1| | 3 |
Rear Brake pipe inadequately supported |3.6.B.1| | 3 |
Brake performance not tested |3.7.A.1| | 3 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 3 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
Exhaust engine idle speed too high |7.3.A.2a| | 3 |
Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 3 |
Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 3 |
Nearside Front Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 3 |
Nearside Rear wheel cylinder leaking |3.6.A.1| | 3 |
Offside Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
Brake pedal spongy |3.3.B.1b| | 3 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 3 |
Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 3 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 3 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
Rear Drag link end ball joint has excessive play |2.2.B.1f| | 3 |
Front brake disc in such a condition that it is seriously weakened | 3 |
Nearside Rear position lamp|s| insecure |1.1.A.3a| | 3 |
Offside Rear position lamp|s| insecure |1.1.A.3a| | 3 |
Offside Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 3 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
Offside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 3 |
Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 3 |
Centre Statutory seat belt missing |5.1.1| | 3 |
Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 3 |
Rear Exhaust mounting missing |7.1.1b| | 3 |
Centre Exhaust system not adequately supported |7.1.1| | 3 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
Nearside Seat belt locking mechanism does not secure or release |5.2.5a| | 3 |
Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 3 |
Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 3 |
Nearside Rear Body insecure and dangerous to other road users |6.1.B.1b| | 3 |
Offside Front Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 3 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 3 |
Nearside Front Body insecure and dangerous to other road users |6.1.B.1b| | 3 |
Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 3 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 3 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
Nearside Front Suspension component mounting prescribed area is excessively corroded over shocker |2.4.A.3| | 2 |
Offside Front Suspension component mounting prescribed area is excessively corroded over shocker |2.4.A.3| | 2 |
Offside Front Suspension component mounting prescribed area is excessively corroded inner wing |2.4.A.3| | 2 |
Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
Vehicle Identification Number not permanently displayed |6.3.5.a| | 2 |
Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 2 |
Nearside Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 2 |
Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 2 |
Offside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 2 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
Horn not loud enough to be heard by another road user |1.6.2b| | 2 |
Offside Front Brake pipe leaking |3.6.A.1| | 2 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Offside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front brake disc excessively pitted |3.5.1h| | 2 |
Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside front brake binding |3.7.B.1| | 2 |
Offside Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |
Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 2 |
Offside Front All position lamps not working |1.1.A.3b| | 2 |
Nearside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front Headlamp insecure |1.7.3| | 2 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 2 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Front Headlamp insecure |1.7.3| | 2 |
Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Steering wheel in a condition that hampers proper control |2.1.1| | 2 |
Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
Offside Rear Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 2 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Front Axle king pin is loose in the axle beam |2.5.A.3a| | 2 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 2 |
Nearside rear brake grabbing severely |3.7.A.5b| | 2 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
Front brake disc excessively pitted |3.5.1h| | 2 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 2 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Offside Inner Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 2 |
Nearside Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 2 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 2 |
Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Headlamp aim not tested |1.8.A.1c| | 2 |
Bonnet cannot be secured in the closed position |8.4.1| | 2 |
Offside Rear rear brake grabbing severely |3.7.A.5b| | 2 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Steering column universal joint has excessive play |2.1.5| | 2 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
All position lamps adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
Nearside Rear Position lamp not working |4.2.1 |a|| | 2 |
Offside Rear Position lamp not working |4.2.1 |a|| | 2 |
Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 2 |
Centre Front Statutory seat belt missing |5.1.1| | 2 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Brake pedal anti-slip provision incomplete |3.3.A.1b| | 2 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
Nearside Rear Upper Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
Nearside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 2 |
Offside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 2 |
Main beam `tell-tale` not working |1.7.4c| | 2 |
Direction indicators adversely affected by the operation of another lamp |1.4.A.2h| | 2 |
Fuel hose leaking |7.2.3| | 2 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 2 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
Centre Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Nearside Front Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 2 |
Exhaust mounting missing |7.1.1b| | 2 |
Nearside Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 2 |
Front Body insecure and dangerous to other road users |6.1.B.1b| | 2 |
Front wheel bearing has excessive play |2.5.A.3c| | 2 |
rear brakes release unevenly |3.7.B.4| | 2 |
Front Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
Offside Front Brake pipe inadequately clipped |3.6.B.1| | 2 |
Offside Front Obligatory mirror missing |8.1.1| | 2 |
Offside Obligatory mirror missing |8.1.1| | 2 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Brake pipe inadequately supported |3.6.B.1| | 2 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
Offside Front Lower Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
Service brake: efficiency below requirements |3.7.D.4| | 2 |
Parking brake: efficiency below requirements |3.7.D.4| | 2 |
Rear fog lamp not working |1.3.2b| | 2 |
Headlamp switch faulty |1.7.1| | 2 |
Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
Exhaust has a part missing |7.1.1a| | 2 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 2 |
Rear Exhaust has a part missing |7.1.1a| | 2 |
Offside Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 2 |
Offside Outer Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Side repeater not working |1.4.A.2c| | 2 |
Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 2 |
Nearside Rear Direction indicators not working |1.4.A.2c| | 2 |
Nearside Rear Fuel hose leaking |7.2.3| | 2 |
Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
Oil leaking excessively from engine (8.4.1 (a) (i)) | 2 |
Nearside Side repeater not working (4.4.1 (a) (ii)) | 2 |
Offside Front Position lamp missing (4.2.1 (a) (ii)) | 2 |
Power steering component leaking (2.1.5 (a)) | 2 |
Rear Brake valve leaking |3.6.A.1| | 2 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
An item not tested |Manual| | 2 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 2 |
Seat belt locking mechanism does not secure or release |5.2.5a| | 2 |