Most common failures | No# failures |
---|
Headlamp aim out of alignment | 11 |
Registration plate lamp issues | 11 |
Service brake: efficiency below requirements |3.7.B.7| | 10 |
Parking brake: efficiency below requirements |3.7.B.7| | 9 |
Brake pipe excessively corroded | 8 |
Windscreen wiper does not clear the windscreen effectively | 7 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Horn not working |1.6.2a| | 5 |
Rear parking brake recording little or no effort | 5 |
Brakes imbalanced across an axle | 5 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Nearside Side repeater not working |1.4.A.2c| | 4 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 3 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
Headlamp switch faulty |1.7.1| | 2 |
Rear fog lamp tell tale not working |1.3.1b| | 2 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
Brake load sensing valve linkage seized |3.6.E.3| | 2 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 2 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
Nearside Front Headlamp insecure |1.7.3| | 2 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
Driver`s seat insecure |6.2.A.1| | 2 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 2 |
Nearside Headlamp not working on main beam |1.7.5a| | 2 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 2 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Offside Rear fog lamp not working |1.3.2b| | 2 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
Windscreen wiper blade insecure | 2 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 2 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Front passenger seat insecure |6.2.3| | 2 |
Front brake disc in such a condition that it is seriously weakened | 2 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Nearside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Offside Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Fuel tank leaking |7.2.3| | 1 |
Offside Front Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Rear Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Fuel system component insecure |7.2.1| | 1 |
Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Rear Exhaust mounting missing |7.1.1b| | 1 |
Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
Nearside Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Offside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
Rear Rear fog lamp not working |1.3.2b| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
Nearside Rear Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 1 |
Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Offside Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Centre Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Registration plate issues | 1 |
Steering box insecure |2.2.B.1a| | 1 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Front Fuel system component insecure |7.2.1| | 1 |
Brake pump/compressor drive belt excessively loose |3.6.F.1| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Nearside Front brake disc has restricted free movement |3.5.1j| | 1 |
Nearside Front Lower Ball joint excessively corroded and unserviceable |2.2.C.1d| | 1 |
Offside Front Lower Ball joint excessively corroded and unserviceable |2.2.C.1d| | 1 |
Offside Front Upper Ball joint excessively corroded and unserviceable |2.2.C.1d| | 1 |
Offside Front Drag link end excessively corroded and unserviceable |2.2.C.1d| | 1 |
Brake servo vacuum pipe deteriorated |3.6.C.1b| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
Offside Side repeater incomplete |1.5.A1b| | 1 |
Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Offside Rear Braking system leaking |3.6.A.1| | 1 |
Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
Offside front brake recording little or no effort |3.7.B.5a| | 1 |
Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Offside Rear Shock absorber has an excessively worn linkage |2.7.4| | 1 |
Nearside Headlamp insecure |1.7.3| | 1 |
Offside Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
Nearside Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside front brake binding |3.7.B.1| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Offside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Rear fog lamp switch faulty |1.3.1a| | 1 |
Nearside Front Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Power steering component|s| leaking |2.3.3b| | 1 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Centre Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Service brake: efficiency below requirements |3.7.D.4| | 1 |
Parking brake: efficiency below requirements |3.7.D.4| | 1 |
Offside Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Rear Rear fog lamp adversely affected by the operation of another lamp |1.3.2f| | 1 |
Nearside Side repeater incomplete |1.5.A1b| | 1 |
Centre Statutory seat belt missing |5.1.1| | 1 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Offside rear brake juddering severely |3.7.A.5b| | 1 |
All position lamps not working |1.1.A.3b| | 1 |
Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Driver`s door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Rear Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Steering pivot point has excessive play |2.2.B.1g| | 1 |
Steering system excessively tight |2.2.D.1| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Rear fog lamp switch inoperative (4.5.3 (a)) | 1 |
Speedometer cannot be illuminated (7.8 (c) (ii)) | 1 |
Rear Exhaust system insecure (6.1.2 (a)) | 1 |
Nearside Front Leaf spring saddle is moving relative to the spring (5.3.1 (a) (ii)) | 1 |
Offside Front Leaf spring saddle is moving relative to the spring (5.3.1 (a) (ii)) | 1 |
Nearside Rear Leaf spring saddle is moving relative to the spring (5.3.1 (a) (ii)) | 1 |
Offside Rear Leaf spring saddle is moving relative to the spring (5.3.1 (a) (ii)) | 1 |
Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 1 |
Nearside Headlamp aim not tested |4.1.2 |b|| | 1 |
Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
Brake load sensing valve inoperative and ABS not fitted or inoperative |1.1.17 |c| |ii|| | 1 |
Nearside Front Side repeater not working |1.4.A.2c| | 1 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Steering column universal joint has excessive play |2.1.5| | 1 |
Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
Centre Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Under Side ( Battery Area) (6.2.2 (d) (i)) | 1 |
Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Step Area (6.1.1 (c) (i)) | 1 |
Emissions not tested EXCESSIVE SMOKE (likely to affect testing equipment) (8.2.2.2 (e)) | 1 |
Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Brake cable guide defective and affecting operation |1.1.15 |d|| | 1 |
Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Emissions not tested |7.0| | 1 |
Offside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
Rear Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
Direction indicators not working |1.4.A.2c| | 1 |
Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Offside Front brake disc excessively pitted |3.5.1h| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Nearside Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Brake master cylinder/servo mounting prescribed area is fractured |3.6.C.3| | 1 |
Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Fuel hose leaking |7.2.3| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Drag link end ball pin shank loose |2.2.B.1c| | 1 |
Offside Track rod end ball pin shank loose |2.2.B.1c| | 1 |
Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |