| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 18 |
| Registration plate lamp issues | 9 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Registration plate issues | 7 |
| Nearside Stop lamp not working |1.2.1b| | 6 |
| Brakes imbalanced across an axle | 6 |
| Offside Stop lamp not working |1.2.1b| | 6 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Rear brake binding | 4 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 4 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 3 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 3 |
| Brake pipe excessively corroded | 3 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 3 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Nearside Side repeater not working |1.4.A.2c| | 3 |
| Windscreen has damage | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 2 |
| Body insecure and dangerous to other road users |6.1.B.1b| | 2 |
| Rear Drag link end ball joint has excessive play |2.2.B.1f| | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Steering system excessively tight |2.2.D.1| | 2 |
| Rear brake application uneven | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Fuel system component leaking excessively or a risk of fire (6.1.3 (b) (ii)) | 2 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Nearside Rear reflector missing (4.8.2 (a) (ii)) | 2 |
| Offside Rear reflector missing (4.8.2 (a) (ii)) | 2 |
| Windscreen washer not working | 2 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Horn not working |1.6.2a| | 2 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
| Steering column universal joint has excessive wear or play (2.2.2 (c)) | 1 |
| Emissions not tested (8.2.2.2 (e)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Body component corroded and likely to cause injury wing support bar adrift at chassis (6.2.1 (a) (i)) | 1 |
| Front Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Steering box has a significant oil leak |2.2.D.2e| | 1 |
| Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Front Steering column universal joint has excessive play |2.1.5| | 1 |
| Offside Front Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Towbar support obviously of an inappropriate size |6.6.2| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Front Fuel system component leaking |7.2.3| | 1 |
| Offside Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
| Nearside Front Headlamp missing |1.7.3| | 1 |
| Offside Front Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Steering column top bearing excessively worn |2.1.2c| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Vehicle structure has a modification which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Wheel nut|s| loose |4.2.A.1e| | 1 |
| Offside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Steering locking device insecure |2.2.C.1g| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Front Shock absorber insecure |2.7.2b| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Stop lamp obviously incorrectly positioned |1.2.1a| | 1 |
| Lower Steering column universal joint has excessive play |2.1.5| | 1 |
| Offside Front Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Steering column universal joint has excessive play |2.1.5| | 1 |
| Front Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Rear Drag link end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Outer Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Fuel hose leaking |7.2.3| | 1 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 1 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Offside Front Steering component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected under bonnet (2.1.2 (e) (ii)) | 1 |
| Nearside Front Inner Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected arch (5.3.6 (a) (ii)) | 1 |
| Offside Front Inner Suspension component mounting prescribed area fractured to the extent that control of the vehicle is likely to be adversely affected arch (5.3.6 (a) (ii)) | 1 |
| Offside Front Suspension component mounting prescribed area fractured to the extent that control of the vehicle is likely to be adversely affected floor (5.3.6 (a) (ii)) | 1 |
| Central Prop shaft bearing excessively worn (6.1.7 (b) (i)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Nearside Headlamp insecure (4.1.1 (c)) | 1 |
| Offside Headlamp insecure (4.1.1 (c)) | 1 |
| Electrical wiring insulation so damaged or deteriorated it is likely to cause a short-circuit engine bay - steering column area (4.11 (c) (ii)) | 1 |
| Offside Rear Brake pipe excessively damaged (1.1.11 (c)) | 1 |
| Nearside Front Suspension component pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Front Drag link end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Towbar attachment insecure (6.1.6 (c) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Obligatory mirror missing |3.3 |a|| | 1 |
| Nearside Rear Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
| Front Suspension component mounting prescribed area is excessively corroded wheel arches |2.4.A.3| | 1 |
| Brake pipe inadequately clipped pipe half way in chassis from front to back |3.6.B.1| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Position lamp switch faulty |1.1.A.1| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Nearside Front suspension has excessive play in a lower wishbone bearing |2.5.B.1a| | 1 |
| Offside Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Rear position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Dropside cannot be secured in the closed position |6.4.1| | 1 |
| Front Body has a projection caused by damage |6.1.C.1| | 1 |
| Offside Outer Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Outer Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Outer Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Exhaust emits excessive smoke or vapour likely to obscure the vision of other road users (8.2.2.2 (c)) | 1 |
| Nearside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced X2 (6.1.1 (c) (i)) | 1 |
| Offside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced X2 (6.1.1 (c) (i)) | 1 |
| Offside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Sill (6.1.1 (c) (i)) | 1 |
| Offside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Arch (6.1.1 (c) (i)) | 1 |
| Offside Front Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Front Bonnet primary retaining device ineffective (3.1 (c)) | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Inner Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Outer Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Lower Shock absorber insecure retorqued |2.7.2b| | 1 |
| Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Rear position lamp|s| not working inner & outer |1.1.A.3b| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Front Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Rear Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Direction indicators not working |1.4.A.2c| | 1 |
| Offside Direction indicators not working |1.4.A.2c| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Offside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
| Offside Headlamp flickers when tapped lightly by hand |1.2.4c| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.2| | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting |6.2.2 |d| |i|| | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced door step |7.1.1 |a| |i|| | 1 |
| Nearside Windscreen wiper missing |3.4 |a|| | 1 |