Most common failures | No# failures |
---|
Registration plate lamp issues | 8 |
Windscreen wiper does not clear the windscreen effectively | 7 |
Brakes imbalanced across an axle | 7 |
Brake pipe excessively corroded | 6 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 4 |
Service brake: efficiency below requirements |3.7.B.7| | 4 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Rear parking brake recording little or no effort | 4 |
Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 3 |
Offside Rear fog lamp not working |1.3.2b| | 3 |
Rear brake application uneven | 3 |
Registration plate issues | 3 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 3 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 3 |
Parking brake: efficiency below requirements |3.7.B.7| | 3 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Headlamp aim out of alignment | 2 |
Rear brake binding | 2 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Steering system excessively rough |2.2.D.1| | 2 |
Offside Steering rack gaiter split |2.2.D.2d| | 2 |
Offside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
Power steering pump leaking from a failed component |2.3.3b| | 2 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 2 |
Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Windscreen has damage | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Horn not working |1.6.2a| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Fuel cap/sealing device mounting flange/sealing method defective |7.2.4c| | 1 |
Offside Rear An item not tested |Manual| | 1 |
Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner and outer sill (7.1.1 (a) (i)) | 1 |
Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced marked in yellow rear of cab (7.1.1 (a) (i)) | 1 |
Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced marked in yellow rear of cab (7.1.1 (a) (i)) | 1 |
Rear Service brake imbalanced across an axle (1.2.1 (b) (i)) | 1 |
Offside Front Hydraulic brake cylinder leaking and braking performance affected (1.1.16 (b) (ii)) | 1 |
Rear Suspension component mounting prescribed area is inadequately repaired both rears marked in yellow (5.3.6 (a) (i)) | 1 |
Central Suspension component mounting prescribed area is inadequately repaired marked in yellow (5.3.6 (a) (i)) | 1 |
Central Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting marked in yellow (6.2.2 (d) (i)) | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Prop shaft bearing excessively worn |6.1.7 |b| |i|| | 1 |
Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Front brake application uneven | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Steering column top bearing excessively worn |2.1.2c| | 1 |
Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Centre Rear Statutory seat belt missing |5.1.1| | 1 |
Windscreen wiper blade insecure | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front brake disc excessively scored |3.5.1h| | 1 |
Offside Front brake disc excessively scored |3.5.1h| | 1 |
Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
Power steering pipe|s| or hose|s| leaking from a seal |2.3.3b| | 1 |
Spare wheel carrier insecure |6.4.2| | 1 |
Parking brake lever, pawl mechanism pivots or their associated mountings are insecure |3.1.4b| | 1 |
Brake cable has restricted free movement |3.5.1k| | 1 |
Offside Front Body has excessive displacement which may lead to loss of vehicle control |6.1.B.1a| | 1 |
Nearside Front Body has excessive displacement which may lead to loss of vehicle control |6.1.B.1a| | 1 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Rear Seat belt flexible stalk deteriorated likely to lead to failure under load |5.2.4a| | 1 |
brake caliper securing device missing |3.5.1j| | 1 |
Nearside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front An item not tested |Manual| | 1 |
Nearside Front Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Nearside Rear Suspension component mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.B.1| | 1 |
Rear Exhaust has a part missing |7.1.1a| | 1 |
Nearside Rear Wheel nut|s| loose |4.2.A.1e| | 1 |
Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
Horn not a continuous or uniform sound |1.6.2e| | 1 |
Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Side repeater not working |1.4.A.2c| | 1 |
Offside Front Battery insecure |1.9.1| | 1 |
Nearside Rear Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
Offside Headlamp not in good working order affecting the beam image |1.2.4a| | 1 |
Offside Headlamp not in good working order affecting light output |1.2.4a| | 1 |
Offside Headlamp aim not tested |1.6| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.1.B.7| | 1 |
Nearside Rear Seat belt adjustment fitting badly deteriorated |5.1.B.4| | 1 |
Offside Front position lamp|s| not in good working order |not working| |1.1.4a| | 1 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded which significantly reduces the original strength |2.4.A.2| | 1 |
Offside Front Suspension spring mounting prescribed area is excessively corroded which significantly reduces the original strength |2.4.A.2| | 1 |
Suspension spring mounting prescribed area is excessively corroded which significantly reduces the original strength |2.4.A.2| | 1 |
Nearside Stub axle has excessive vertical movement between stub axle and axle beam |2.5.A.1a| | 1 |
Emissions not tested won`t idle |8.2.1.2 |d|| | 1 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Braking system leaking |3.6.A.1| | 1 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Offside Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Nearside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Rear Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Front Brake clevis joint locking device missing |3.5.1l| | 1 |
Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Front Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Nearside Seat belt stitching badly frayed |5.2.2b| | 1 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 1 |