Most common failures | No# failures |
---|
Headlamp aim out of alignment | 4 |
Brakes imbalanced across an axle | 4 |
Rear brake binding | 4 |
Parking brake: efficiency below requirements |3.7.B.7| | 3 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
Rear parking brake recording little or no effort | 2 |
Parking brake lever has no reserve travel |3.1.6b| | 2 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
Registration plate issues | 2 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
Rear Mechanical brake component has restricted free movement | 2 |
Brake pipe excessively corroded | 2 |
Windscreen wiper does not clear the windscreen effectively | 2 |
Braking system leaking |3.6.A.1| | 2 |
Offside rear brake recording little or no effort |3.7.B.5a| | 2 |
Nearside front brake binding |3.7.B.1| | 2 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Mechanical brake component has restricted free movement | 2 |
Service brake: efficiency below requirements |3.7.B.7| | 2 |
Windscreen wiper blade insecure | 2 |
Offside Front front brake binding |3.7.B.1| | 2 |
Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Stop lamp not working |1.2.1b| | 1 |
Nearside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Horn not working |1.6.2a| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Steering column shaft has excessive end float |2.1.3| | 1 |
Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
Offside Rear Suspension weakened allowing body or other component to foul a road wheel or would do so if laden |2.4.A.1b| | 1 |
Exhaust emits clearly visible black smoke during acceleration |7.3.A.2c| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Rear brake application uneven | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Offside Front Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
Offside Front Headlamp does not operate immediately when selected on dipped beam |1.7.4a| | 1 |
Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings frame/floor |6.1.B.2| | 1 |
Offside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
Front Fuel system component insecure |7.2.1| | 1 |
Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front Upper Suspension arm attachment bracket/mounting damaged and its strength is seriously reduced |2.4.G.1| | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Brake pipe inadequately clipped |3.6.B.1| | 1 |
Steering column has excessive movement up and down (2.2.2 (a)) | 1 |
Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
Nearside Front Suspension rod pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Suspension rod pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Offside Front Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Nearside Front Seat belt missing (7.1.2 (a)) | 1 |
Offside Front Seat belt missing (7.1.2 (a)) | 1 |
Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
Parking (secondary brake) on a single line braking system imbalanced across an axle Axle 1 (1.3.1 (b) (i)) | 1 |
Rear Rear position lamp|s| missing |1.1.A.3a| | 1 |
Offside front brake binding |3.7.B.1| | 1 |
Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Offside Front Upper Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Nearside Front Upper Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Nearside Front Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Coil spring not correctly located |2.4.C.2| | 1 |
Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
Mechanical brake component securing device loose |3.5.1i| | 1 |
Indicator switch faulty |1.4.A.1| | 1 |
Front Headlamp switch faulty |1.7.1| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Nearside Front suspension has excessive movement at wishbone bearing |2.5.A.1c| | 1 |
Offside Upper Brake pipe leaking |3.6.A.1| | 1 |
Brake hose excessively deteriorated | 1 |
Offside Rear Coil spring not correctly located |2.4.C.2| | 1 |
Centre Electrical wiring insecure |1.9.2a| | 1 |
Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Steering rack damaged and unserviceable |2.2.C.1d| | 1 |
Centre Exhaust system not adequately supported |7.1.1| | 1 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Battery insecure |1.9.1| | 1 |
Nearside Rear Brake pipe kinked |3.6.B.2b| | 1 |
Offside Front front brake grabbing severely |3.7.A.2b| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Registration plate lamp issues | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Offside Rear Electrical wiring insecure |1.9.2a| | 1 |
Speedometer cannot be illuminated. |6.7.3| | 1 |
Nearside Front All position lamps not working |1.1.A.3b| | 1 |
Nearside Rear All position lamps not working |1.1.A.3b| | 1 |
Offside Front coil spring broken |2.4.C.1a| | 1 |
Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Lower Steering column universal joint insecure onto rack |2.1.3 |a| |i|| | 1 |
All direction indicators not working |4.4.1 |a| |ii|| | 1 |
Nearside Front Lower Shock absorbers insecurely attached bolt snapped |5.3.2 |a| |i|| | 1 |
Nearside Front Upper Suspension arm pin or bush excessively worn bush |5.3.4 |a| |i|| | 1 |
Nearside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
All direction indicators not working (4.4.1 (a) (ii)) | 1 |
Nearside Rear Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
Offside Rear Shock absorbers insecurely attached (5.3.2 (a) (i)) | 1 |
Offside Front Upper Suspension arm pin or bush excessively worn top arm bush (5.3.4 (a) (i)) | 1 |