| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 10 |
| Brake pipe excessively corroded | 7 |
| Registration plate issues | 7 |
| Offside Rear fog lamp not working |1.3.2b| | 5 |
| Brake hose excessively deteriorated | 4 |
| Headlamp aim out of alignment | 3 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 3 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Front position lamp|s| not working |1.1.A.3b| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Emissions unable to be completed CO too high. (8.2.1.2 (d)) | 1 |
| Windscreen washer not working | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition (8.1.1 (a)) | 1 |
| Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Emissions oxygen sensor obviously modified disconnected (8.2.1.1 (a)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Prop shaft securing bolt missing (6.1.7 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Brakes imbalanced across an axle | 1 |
| Shock absorber insecure both front |2.7.2b| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings chassis near fuel tank area |6.1.B.2| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp indicator |1.1.A.3f| | 1 |
| Side repeater not working |1.4.A.2c| | 1 |
| Rear Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Rear Leaf spring shackle bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Headlamp has a product on the lens so that the light output is severely reduced o/s and n/s |4.1.4 |b|| | 1 |
| Offside Rear Brake pipe leaking on a hydraulic braking system |1.1.11 |b| |ii|| | 1 |
| Brake performance not tested brake pipe split end of test |1.2.1 |g|| | 1 |
| Spare wheel insecure |6.4.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Stop lamp(s) all missing (4.3.1 (a) (iii)) | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Front Radius arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Offside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Nearside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Rear Brake pipe kinked |3.6.B.2b| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Power steering pump leaking from a failed component |2.3.3b| | 1 |
| Offside Front Brake pipe seriously damaged |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Power steering fluid level below minimum |2.3.1| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Offside Front Side repeater insecure |1.4.A.2b| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |