| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 23 |
| Windscreen wiper does not clear the windscreen effectively | 13 |
| Headlamp aim out of alignment | 13 |
| Brakes imbalanced across an axle | 10 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 10 |
| Rear parking brake recording little or no effort | 8 |
| Parking brake: efficiency below requirements |3.7.B.7| | 7 |
| Nearside Stop lamp not working |1.2.1b| | 7 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 5 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 5 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 4 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Brake hose excessively deteriorated | 3 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Windscreen wiper blade deteriorated |8.2.2| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Rear brake binding | 2 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 2 |
| Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 2 |
| Offside Front Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 2 |
| Nearside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 2 |
| Registration plate issues | 2 |
| Nearside Seat belt anchorage prescribed area is excessively corroded inner sill |5.2.6| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded inner wheel arch |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded inner wheel arch |5.2.6| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner wheel arch |6.1.B.2| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Nearside Front Steering component mounting prescribed area is excessively corroded crossmember (below radiator ) (2.1.2 (e) (i)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced visible through offside rear wheel arch (7.1.1 (a) (i)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Steering component mounting prescribed area is excessively corroded crossmember( below radiator ) (2.1.2 (e) (i)) | 1 |
| Emissions not tested exhaust leak (8.2.2.2 (e)) | 1 |
| Windscreen washer not working | 1 |
| Offside Rear Brake hose leaking on a hydraulic braking system centre (1.1.12 (c) (ii)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill (7.1.1 (a) (i)) | 1 |
| Offside Rear Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Central Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting nearside (6.2.2 (d) (i)) | 1 |
| Central Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting offside (6.2.2 (d) (i)) | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Rear Braking system leaking |3.6.A.1| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Power steering pump drive system defective |2.3.6| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Windscreen has damage | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Brake pipe seriously damaged |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Headlamp aim not tested |1.8.A.1c| | 1 |
| Horn not working |1.6.2a| | 1 |
| Centre Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Steering locking device missing |2.2.C.1g| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Front Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Registration plate lamp issues | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
| Nearside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Outer Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Front Upper Suspension arm locating pin retaining device not properly locked |2.4.G.3b| | 1 |
| Nearside Front Lower Suspension arm locating pin retaining device not properly locked |2.4.G.3b| | 1 |
| Offside Front Upper Suspension arm locating pin retaining device not properly locked |2.4.G.3b| | 1 |
| Offside Front Lower Suspension arm locating pin retaining device not properly locked |2.4.G.3b| | 1 |
| Nearside Upper Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Offside Rear Upper Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Nearside Front Direction indicator insecure |1.4.A.2b| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Mechanical brake component securing device excessively deteriorated |3.5.1i| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Rear Brake pipe excessively chafed |3.6.B.2c| | 1 |
| Headlamp aim beam image obviously incorrect both |1.8.A.1b| | 1 |
| Headlamp not working on main beam both |1.7.5a| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Outer Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Electrical wiring inadequately supported |1.9.2a| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Outer Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Outer Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced OUTER SILL (6.1.1 (c) (i)) | 1 |
| Offside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced OUTER SILL (6.1.1 (c) (i)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |