| Most common failures | No# failures |
|---|
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 9 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 6 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Reversing lamp inoperative (4.6.1 (a)) | 5 |
| Headlamp aim out of alignment | 5 |
| Brake pipe excessively corroded | 5 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 4 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Exhaust emissions exceed manufacturer`s specified limit |8.2.2.2 |a|| | 3 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 3 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 3 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Rear Seat belt damaged (7.1.2 (b) (i)) | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 2 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Rear Hydraulic brake calliper leaking and braking performance affected (1.1.16 (b) (ii)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Nearside Front Body component damaged and likely to cause injury wing mirror plastic trim missing (6.2.1 (a) (i)) | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Front Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Front Windscreen damaged and affecting the drivers view of the road Windscreen cracked (3.2 (a) (ii)) | 1 |
| Nearside Front Headlamp aim not tested (4.1.2 (b)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect Bulb not in correctly (4.1.2 (c)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Exhaust emissions exceed manufacturers specified limit Plate limit 0.5 m/1 (8.2.2.2 (a)) | 1 |
| Exhaust emissions exceed manufacturers specified limit Plate limit 0.5 1/m (8.2.2.2 (a)) | 1 |
| Exhaust emissions exceed manufacturers specified limit Data plate limit of 0.5 m/1 (8.2.2.2 (a)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear reflector defective or damaged by more than 50% of the reflecting surface (4.8.1 (a) (ii)) | 1 |
| Offside Rear Seat belt buckle not functioning as intended (7.1.2 (d)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Emission control equipment obviously defective (8.2.2.1 (a)) | 1 |
| Nearside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Lower Drivers seat with a defective structure (6.2.5 (a) (i)) | 1 |
| Brake performance not tested Rear pipes (1.2.1 (g)) | 1 |
| Exhaust fumes causing a danger to health of persons on board rear tip corroded off (6.1.2 (b) (ii)) | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Exhaust emissions exceed default limit of 0.7m-1 (8.2.2.2 (b)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn Front bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn Front bush (5.3.4 (a) (i)) | 1 |
| Exhaust system insecure centre mount broke |6.1.2 |a|| | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Offside Rear Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Offside Rear Brake lever has restricted free movement AT BRAKE CALIPER CAUSING BINDING (1.1.15 (e)) | 1 |
| Central Exhaust silencer insecure EXHAUST MOUNTING RUBBER BROKEN (8.1.1 (b) (i)) | 1 |
| Drivers seat insecure (6.2.5 (a) (ii)) | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Offside Rear Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Brake cable damaged broken (1.1.15 (a)) | 1 |
| Offside Rear Brake cable guide defective and affecting operation (1.1.15 (d)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Headlamp insecure (4.1.1 (c)) | 1 |
| Offside Rear Seat belt webbing significantly weakened of rear (7.1.2 (b) (ii)) | 1 |
| Nearside Rear Seat belt webbing significantly weakened of rear (7.1.2 (b) (ii)) | 1 |
| Exhaust emissions exceed manufacturers specified limit 0.55 (8.2.2.2 (a)) | 1 |
| Nearside Rear Seat belt damaged centre row outer (7.1.2 (b) (i)) | 1 |
| Offside Rear Brake cable damaged Cable snapped at caliper (1.1.15 (a)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Central Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Seat belt webbing significantly weakened Centre row (7.1.2 (b) (ii)) | 1 |
| Nearside Rear Seat belt webbing significantly weakened (7.1.2 (b) (ii)) | 1 |
| Offside Rear Seat belt damaged of rear lower part of webbing (7.1.2 (b) (i)) | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values (8.2.2.2 (f)) | 1 |
| Registration plate lamp issues | 1 |
| Nearside Rear Seat belt webbing significantly weakened last row (7.1.2 (b) (ii)) | 1 |
| Offside Rear Seat belt webbing significantly weakened last row (7.1.2 (b) (ii)) | 1 |
| Nearside Rear Seat belt damaged (7.1.2 (b) (i)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Rear Outer Seat belt damaged |7.1.2 |b| |i|| | 1 |
| Rear Exhaust system insecure bracket broken away (6.1.2 (a)) | 1 |
| Rear Brake disc significantly and obviously worn both sides (1.1.14 (a) (i)) | 1 |
| Central Rear Lower Bumper damaged and likely to cause injury when grazed or contacted trim and cover for bumper hanging of (6.1.4 (a) (i)) | 1 |
| Offside Rear Fuel hose damaged (6.1.3 (c) (ii)) | 1 |
| Offside Front Inner Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Bumper damaged and likely to cause injury when grazed or contacted (6.1.4 (a) (i)) | 1 |
| Front Steering lock stop incorrectly adjusted Both (2.1.4 (b)) | 1 |
| Offside Rear Fuel pipe damaged (6.1.3 (c) (ii)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |