Most common failures | No# failures |
---|
Headlamp aim out of alignment | 25 |
Parking brake: efficiency below requirements |3.7.B.7| | 24 |
Rear parking brake recording little or no effort | 23 |
Registration plate lamp issues | 22 |
Brake pipe excessively corroded | 20 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 12 |
Brake hose excessively deteriorated | 8 |
Service brake: efficiency below requirements |3.7.B.7| | 8 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 8 |
Windscreen wiper does not clear the windscreen effectively | 8 |
Offside Rear fog lamp not working |1.3.2b| | 7 |
Registration plate issues | 7 |
Offside Rear Rear fog lamp not working |1.3.2b| | 6 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
Horn not working |1.6.2a| | 5 |
Offside Stop lamp not working |1.2.1b| | 5 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 5 |
Brakes imbalanced across an axle | 5 |
Brake hose has insufficient room to move | 4 |
Rear brake binding | 4 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Nearside Stop lamp not working |1.2.1b| | 4 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
Offside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 3 |
Driver`s seat insecure |6.2.A.1| | 3 |
Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
Offside Front Direction indicator not working |1.4.A.2c| | 2 |
Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 2 |
Offside Headlamp not working on main beam |1.7.5a| | 2 |
Nearside front brake binding |3.7.B.1| | 2 |
Offside front brake binding |3.7.B.1| | 2 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
Offside Front Position lamp not working |4.2.1 |a|| | 2 |
Brake pedal spongy |3.3.B.1b| | 2 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 2 |
Offside Front Shock absorber has an excessively worn bush |2.7.4| | 2 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 2 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
Offside Windscreen wiper blade deteriorated |8.2.2| | 2 |
Offside Front Tie bar/rod synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 2 |
Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Nearside Rear Stop lamp not working |1.2.1b| | 2 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Brake pipe inadequately clipped |3.6.B.1| | 2 |
Front Brake pipe inadequately clipped |3.6.B.1| | 2 |
Front position lamp|s| not working |1.1.A.3b| | 2 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 2 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 2 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 2 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 2 |
Offside Rear Brake pipe fouled by moving parts |3.6.B.2a| | 2 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
Exhaust engine idle speed too high |7.3.A.2a| | 1 |
Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Nearside Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Parking brake mechanism/associated mounting prescribed area is excessively corroded |3.1.9| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Front Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
Offside Front Brake pipe leaking |3.6.A.1| | 1 |
Brake cable knotted |3.5.1b| | 1 |
Exhaust has a major leak of exhaust gases All joints |7.1.2| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Fuel cap/sealing device sealing washer deteriorated |7.2.4c| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Inner Rear Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
All position lamps adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Direction indicators incorrect colour |1.4.A.2f| | 1 |
Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Windscreen has damage | 1 |
Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Front Power steering pipe|s| or hose|s| fouling other parts of the vehicle |2.3.2| | 1 |
Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Front Front position lamp|s| insecure |1.1.A.3a| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Centre Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Offside Rear fog lamp missing |4.5.1 |a| |ii|| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Battery insecure |1.9.1| | 1 |
Electrical wiring deteriorated, likely to become detached wiring to positive termanal on battery insecure in spade connector |1.9.2b| | 1 |
Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Nearside Rear Service brake excessively fluctuating |1.2.1 |e|| | 1 |
Offside Rear Service brake excessively fluctuating |1.2.1 |e|| | 1 |
Nearside Front Upper Suspension component mounting prescribed area is inadequately repaired |5.3.6 |a| |i|| | 1 |
Nearside Front Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
Nearside Rear Suspension component mounting prescribed area is inadequately repaired |5.3.6 |a| |i|| | 1 |
Offside Rear Suspension component mounting prescribed area is inadequately repaired |5.3.6 |a| |i|| | 1 |
Nearside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
Nearside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
Offside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
Rear fog lamp switch missing |1.3.1a| | 1 |
Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Rear Rear fog lamp missing |1.3.2a| | 1 |
Offside Direction indicator incorrect colour |1.4.A.2f| | 1 |
Front Windscreen wiper blade missing |8.2.2| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
Offside Front coil spring fractured |2.4.C.1a| | 1 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
Offside Front brake disc excessively pitted |3.5.1h| | 1 |
Nearside Front Tie bar/rod synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Centre Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Centre Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Front Exhaust system not adequately supported |7.1.1| | 1 |
Parking brake lever has no reserve travel |3.1.6b| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Side repeater not working |1.4.A.2c| | 1 |
Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Front Front passenger seat insecure |6.2.3| | 1 |
Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Front brake disc excessively scored |3.5.1h| | 1 |
Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Offside Rear Lower Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
Offside Front Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Lower Rear fog lamp not working |1.3.2b| | 1 |
Nearside Front Upper Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Centre Rear Lower Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
Nearside Front Tie bar/rod attachment bracket/mounting corroded and its strength is seriously reduced |2.4.G.1| | 1 |
Nearside Rear Body has a projection caused by damage |6.1.C.1| | 1 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
Hazard warning lamps inoperative |1.4.B.1b| | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Vehicle Identification Number not permanently displayed |6.3.5.a| | 1 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
Nearside Exhaust system not adequately supported |7.1.1| | 1 |
Emissions not tested |7.0| | 1 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 1 |
Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Headlamp aim beam image too far to the right |1.6.B4| | 1 |
Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Obligatory mirror insecure |8.1.1| | 1 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Brake stationary pin locking device insecure |3.5.1l| | 1 |
Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Stop lamp remains on when the brakes are released | 1 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Outer Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Steering box fractured and unserviceable |2.2.C.1d| | 1 |
Offside Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
Offside Front brake disc cracked |3.5.1h| | 1 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Centre Rear Spare wheel carrier insecure |6.4.2| | 1 |
Offside Rear fog lamp missing |1.3.2a| | 1 |
Rear fog lamp switch faulty |1.3.1a| | 1 |
Nearside Front brake caliper has restricted free movement |3.5.1k| | 1 |
Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
Direction indicators not working |1.4.A.2c| | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Centre Rear Fuel system component insecure |7.2.1| | 1 |
Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
Nearside Front front brake grabbing severely |3.7.A.2b| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Rear position lamp|s| insecure |1.1.A.3a| | 1 |
Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Headlamp insecure |1.7.3| | 1 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Rear An item not tested |Manual| | 1 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Emissions not tested |7.3.A.1| | 1 |
Rear fog lamp tell tale missing |1.3.1b| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Rear Rear fog lamp not working |1.3.2b| | 1 |
Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Rear Position lamp has a product on the lens or light source which shows white light to the rear |4.2.3 |b| |ii|| | 1 |
Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced body to chassis mount |6.1.1 |c| |i|| | 1 |
Nearside Rear reflector missing |1.5.1a| | 1 |
Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Nearside Front Upper Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Upper Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
Nearside Brake pipe inadequately clipped |3.6.B.1| | 1 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
Offside Front Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
Centre Front Rear fog lamp tell tale not working |1.3.1b| | 1 |
Offside Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings inner sill |6.1.B.2| | 1 |
All position lamps not working |1.1.A.3b| | 1 |
Offside Integral body structure strengthening plate or fastening so insecure that structural rigidity is seriously reduced inner sill |6.1.1 |b| |ii|| | 1 |
Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Horn not working (7.7 (a) (ii)) | 1 |
All direction indicators not working (4.4.1 (a) (ii)) | 1 |
Front Headlamp not working on main beam both (4.1.1 (a) (ii)) | 1 |
Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced bulkhead (6.1.1 (c) (i)) | 1 |
Nearside Front Seat belt anchorage prescribed area is inadequately repaired (7.1.1 (a) (i)) | 1 |
Offside Front Seat belt anchorage prescribed area is inadequately repaired (7.1.1 (a) (i)) | 1 |
Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
Rear brake application uneven | 1 |
Offside Front Body has a sharp edge caused by corrosion Arch |6.1.C.1| | 1 |
Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Nearside Rear Lower Stop lamp not working |1.2.1b| | 1 |