Most common failures | No# failures |
---|
Headlamp aim out of alignment | 22 |
Rear brake binding | 18 |
Parking brake: efficiency below requirements |3.7.B.7| | 17 |
Rear parking brake recording little or no effort | 10 |
Windscreen wiper does not clear the windscreen effectively | 9 |
Brakes imbalanced across an axle | 9 |
Registration plate lamp issues | 6 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
Brake pipe excessively corroded | 4 |
Service brake: efficiency below requirements |3.7.B.7| | 4 |
Parking brake: efficiency below requirements |3.7.C.1b| | 4 |
Parking brake lever has no reserve travel |3.1.6b| | 4 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 3 |
Horn not working |1.6.2a| | 3 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
Nearside Front Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Nearside Stop lamp not working |1.2.1b| | 2 |
Offside Stop lamp not working |1.2.1b| | 2 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Fuel system component leaking |7.2.3| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 2 |
Nearside Front Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 2 |
Nearside Front front brake recording little or no effort |3.7.B.5a| | 2 |
Offside Front front brake recording little or no effort |3.7.B.5a| | 2 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
Brake hose excessively deteriorated | 2 |
Offside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 2 |
Offside Front Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 2 |
Driver`s seat insecure |6.2.A.1| | 2 |
Brake performance not tested |3.7.A.1| | 2 |
Nearside front brake binding |3.7.B.1| | 2 |
Nearside Front Braking system leaking |3.6.A.1| | 2 |
Nearside Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Offside Front Brake pipe kinked |3.6.B.2b| | 1 |
Rear Brake hose excessively damaged |3.6.B.4d| | 1 |
Service brake: efficiency below requirements |3.7.C.1a| | 1 |
Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Nearside Rear Service brake: efficiency below requirements |3.7.B.7| | 1 |
Offside Front front brake binding |3.7.B.1| | 1 |
Offside Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Drag link end ball pin shank loose |2.2.B.1c| | 1 |
Offside Rear Leaf spring shackle pin excessively loose in its bracket |2.4.B.3a| | 1 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Nearside Front Suspension arm ball joint dust cover missing |2.4.G.2| | 1 |
Nearside Rear Brake pivot has restricted free movement |3.5.1k| | 1 |
Offside Rear Brake pivot has restricted free movement |3.5.1k| | 1 |
Rear brake application uneven | 1 |
Steering box cracked and unserviceable |2.2.C.1d| | 1 |
Brake pedal has insufficient reserve travel |1.1.2 |a|| | 1 |
Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
Brake performance not tested |1.2.1 |g|| | 1 |
Nearside Front Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Steering component mounting prescribed area is inadequately repaired |2.2.C.1h| | 1 |
Nearside Front Front position lamp|s| insecure |1.1.A.3a| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Offside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
Ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Offside Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
Nearside Front Headlamp not in a clean condition affecting beam image |1.2.4a| | 1 |
Offside Front Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
Offside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Brake hose has insufficient room to move | 1 |
Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Parking brake lever is impeded in its travel |3.1.6c| | 1 |
front brakes release unevenly |3.7.B.4| | 1 |
rear brakes release unevenly |3.7.B.4| | 1 |
Offside Steering rack gaiter split |2.2.D.2d| | 1 |
Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
Nearside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Offside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Rear Shock absorber insecure lower fixing loose |2.7.2b| | 1 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Stop lamp not working Both only work after considerable pedal travel |1.2.1b| | 1 |
Braking system leaking Rear "T" piece by brake light switch |3.6.A.1| | 1 |
Nearside Front Upper Suspension arm insecure rear fixing insecure due to bolt too short to reach nyloc of nut |2.4.G.1| | 1 |
Offside Front Lower Suspension arm insecure rear fixing insecure due to bolt too short to reach nyloc of nut |2.4.G.1| | 1 |
Nearside Front Shock absorber insecure excessive play in upper fixing |2.7.2b| | 1 |
Offside Front Shock absorber insecure excessive play in upper fixing |2.7.2b| | 1 |
Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
Offside Rear Suspension spring mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
Rear Brake pipe inadequately supported |3.6.B.1| | 1 |
Centre Rear Fuel system component insecure |7.2.1| | 1 |
Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Inner Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Front Service brake is causing the steering wheel to severely pull one way |3.7.C.2| | 1 |
Nearside Front Upper Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear brake caliper securing device loose |3.5.1j| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Outer Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Fuel pipe insecure |7.2.1| | 1 |
Front brake application uneven | 1 |
Front Brake actuating linkage mounting prescribed area is inadequately repaired |3.3.A.2| | 1 |
Steering column top mounting bracket insecure |2.1.2d| | 1 |
Rear Braking system leaking |3.6.A.1| | 1 |
Nearside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Inner Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Offside Inner Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
Rear Brake rod has restricted free movement |3.5.1k| | 1 |
Nearside Front Front suspension locking device missing |2.5.A.4| | 1 |
Offside Indicator tell tale inoperative |1.4.A.2a| | 1 |
Nearside Front suspension locking device missing |2.5.A.4| | 1 |
Offside Front suspension locking device missing |2.5.A.4| | 1 |
Offside Front Steering locking device missing |2.2.C.1g| | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside front brake recording little or no effort |3.7.B.5a| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
Nearside Rear brake drum contaminated by brake fluid |3.5.1h| | 1 |
Nearside Front Headlamp flickers when tapped lightly by hand |1.2.4c| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Rear Vehicle structure is cracked, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Nearside Outer Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
Offside Rear Hydraulic brake cylinder leaking hydraulic fluid |3.6.A.1| | 1 |
Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Brake cable has restricted free movement |3.5.1k| | 1 |
Offside Brake cable has restricted free movement |3.5.1k| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |