Most common failures | No# failures |
---|
Registration plate lamp issues | 44 |
Headlamp aim out of alignment | 42 |
Windscreen wiper does not clear the windscreen effectively | 32 |
Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 19 |
Brake load sensing valve linkage seized |3.6.E.3| | 15 |
Brakes imbalanced across an axle | 11 |
Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 10 |
Registration plate issues | 9 |
Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 8 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 7 |
Rear Brake load sensing valve linkage seized |3.6.E.3| | 7 |
Brake pipe excessively corroded | 6 |
Brake load sensing valve seized |3.6.E.3| | 6 |
Windscreen has damage | 5 |
Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 5 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 5 |
Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
Offside Stop lamp not working |1.2.1b| | 5 |
Nearside Stop lamp not working |1.2.1b| | 4 |
Offside rear brake recording little or no effort |3.7.B.5a| | 4 |
Service brake: efficiency below requirements |3.7.B.7| | 4 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
Nearside Rear wheel bearing has excessive play |2.6.2| | 4 |
Horn not working |1.6.2a| | 4 |
Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
Rear parking brake recording little or no effort | 3 |
Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
Rear brake application uneven | 3 |
Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
Rear Brake cable insecure | 3 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 3 |
Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 3 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
Offside Front coil spring incomplete |2.4.C.1a| | 2 |
Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
rear brakes release unevenly |3.7.B.4| | 2 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
Offside Front front brake binding |3.7.B.1| | 2 |
Rear brake binding | 2 |
Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 2 |
Rear Exhaust system not adequately supported |7.1.1| | 2 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded inner seal |2.4.A.3| | 2 |
Parking brake: efficiency below requirements |3.7.B.7| | 2 |
Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Centre Obligatory mirror missing |8.1.1| | 1 |
Centre Exhaust system not adequately supported |7.1.1| | 1 |
Offside Rear Suspension spring mounting prescribed area is fractured |2.4.A.3| | 1 |
Nearside Front coil spring broken |2.4.C.1a| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Windscreen wiper blade insecure | 1 |
Offside Rear fog lamp not working |1.3.2b| | 1 |
Brake valve damaged |3.6.A.2c| | 1 |
Brake load sensing valve linkage obviously incorrectly adjusted |3.6.E.3| | 1 |
Nearside Front Valve stem seriously misaligned |4.1.D.1e| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
Nearside Rear Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings chaissis by rear spring mount |6.1.B.2| | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings by rear spring mount |6.1.B.2| | 1 |
Centre Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings cross member |6.1.B.2| | 1 |
Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
Nearside Direction indicators have less than 50% of the light sources illuminating |1.4.A.2c| | 1 |
Offside Direction indicators have less than 50% of the light sources illuminating |1.4.A.2c| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Rear Brake load sensing valve seized |3.6.E.3| | 1 |
Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
Brake hose damaged | 1 |
Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength front hanger (5.3.6 (a) (i)) | 1 |
Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength front hanger (5.3.6 (a) (i)) | 1 |
Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength shock mount (5.3.6 (a) (i)) | 1 |
Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
Nearside Rear Upper Suspension spring mounting prescribed area is excessively corroded above leaf spring |2.4.A.3| | 1 |
Offside Rear Upper Suspension spring mounting prescribed area is excessively corroded above leaf spring |2.4.A.3| | 1 |
Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Direction indicators not working |1.4.A.2c| | 1 |
Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Exhaust mounting missing |7.1.1b| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Rear Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
Nearside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
Offside Front Macpherson strut has excessive movement at the upper attachment |2.5.A.1c| | 1 |
Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Front Outer Suspension component mounting prescribed area is excessively corroded Sill |2.4.A.3| | 1 |
Nearside Front Outer Suspension component mounting prescribed area is excessively corroded Sill |2.4.A.3| | 1 |
Nearside Rear Outer Suspension component mounting prescribed area is excessively corroded Sill |2.4.A.3| | 1 |
Fuel pipe leaking |7.2.3| | 1 |
Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Front brake caliper leaking |3.6.A.1| | 1 |
Rear Brake load sensing valve linkage defective and function impaired |3.6.E.3| | 1 |
Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
Offside Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Front brake application uneven | 1 |
Offside Front Wheel stud|s| missing |4.2.A.1e| | 1 |
Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Nearside Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Nearside Front brake disc excessively scored |3.5.1h| | 1 |
Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Nearside Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
Offside Direction indicators flashing less than 60 times a minute |1.4.A.2g| | 1 |
Offside Headlamp insecure |1.7.3| | 1 |
Nearside Front Side repeater not working |1.4.A.2c| | 1 |
Offside Front Side repeater not working |1.4.A.2c| | 1 |
Nearside Front Seat belt has a cut which has significantly weakened the webbing |5.2.2a| | 1 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Front brake disc excessively pitted |3.5.1h| | 1 |
Nearside Rear Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings and o/s cross member |6.1.B.2| | 1 |
Spare wheel carrier insecure |6.4.2| | 1 |
Emissions not tested |7.0| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Nearside Rear Shock absorber casing damaged externally so the unit does not function |2.7.2a| | 1 |
Offside Rear Shock absorber casing damaged externally so the unit does not function |2.7.2a| | 1 |
Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
Offside Front Obligatory mirror insecure |8.1.1| | 1 |
Rear Rear fog lamp not working |1.3.2b| | 1 |
Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Offside Front Suspension arm has excessive play in a pin/bearing lower wishbone. o/s front. |2.4.G.2| | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Battery insecure |1.9.1| | 1 |
Offside Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
Windscreen wiper not working (3.4 (a)) | 1 |
Windscreen washer not working | 1 |
Offside Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 1 |
Exhaust has a major leak of exhaust gases Rear silencer missing (6.1.2 (a)) | 1 |
Emissions not tested Due to exhaust missing (8.2.1.2 (d)) | 1 |
Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
Nearside Front position lamp|s| excessively damaged so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Fuel system component leaking |7.2.3| | 1 |
Rear Stop lamp not working |1.2.1b| | 1 |
Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance |1.2.1d| | 1 |
Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
Front Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Offside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Offside Rear Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
Offside Seat belt anchorage prescribed area is excessively corroded floor panel |5.2.6| | 1 |
Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front Seat belt flexible stalk deteriorated likely to lead to failure under load |5.2.4a| | 1 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded spring hanger |2.4.A.3| | 1 |
Offside Front Body has a projection caused by damage |6.1.C.1| | 1 |
Offside Brake cable insecure |3.5.1d| | 1 |
Fuel hose insecure |7.2.1| | 1 |
Rear fog lamp not working |1.3.2b| | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Headlamp not working on dipped beam |1.7.5a| | 1 |
Offside Inner Ball joint has excessive play rack |2.2.B.1f| | 1 |
Offside Rear Suspension spring mounting prescribed area is excessively corroded front spring hanger |2.4.A.3| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded spring hanger |2.4.A.3| | 1 |
Nearside Rear Suspension spring mounting prescribed area is excessively corroded inner seal |2.4.A.3| | 1 |
Offside Front Subframe mounting prescribed area is excessively corroded seal |2.4.A.3| | 1 |
Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Emissions not tested (8.2.1.2 (d)) | 1 |
Exhaust catalytic converter missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
Nearside Lower Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Exhaust emits excessive dense blue smoke during acceleration |7.3.A.2c| | 1 |