| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 148 |
| Headlamp aim out of alignment | 106 |
| Brake pipe excessively corroded | 92 |
| Windscreen wiper does not clear the windscreen effectively | 72 |
| Brakes imbalanced across an axle | 30 |
| Offside Stop lamp not working |1.2.1b| | 27 |
| Parking brake: efficiency below requirements |3.7.B.7| | 25 |
| Nearside Stop lamp not working |1.2.1b| | 24 |
| Registration plate issues | 23 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 20 |
| Centre Stop lamp not working |1.2.1b| | 20 |
| Windscreen has damage | 17 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 16 |
| Anti-lock braking system warning lamp indicates an ABS fault | 15 |
| Nearside Rear Stop lamp not working |1.2.1b| | 15 |
| Rear parking brake recording little or no effort | 14 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 14 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 13 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 13 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 13 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 12 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 12 |
| Rear brake application uneven | 12 |
| Offside Rear Stop lamp not working |1.2.1b| | 11 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 11 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 11 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 11 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 10 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 9 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 9 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 9 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 9 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 8 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 8 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 8 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 8 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 8 |
| Windscreen washer not working | 7 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 7 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 7 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 7 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 7 |
| Centre Rear Stop lamp not working |1.2.1b| | 7 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 7 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 6 |
| Engine MIL inoperative or indicates a malfunction |8.2.2.2 |g|| | 6 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 6 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 6 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 6 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 6 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 6 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 6 |
| Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 6 |
| Battery insecure |1.9.1| | 6 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 6 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 5 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 5 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 5 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 5 |
| Nearside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 5 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 5 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 5 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 5 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 5 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 5 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 5 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 5 |
| Offside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 5 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 5 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 5 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 5 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 4 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Offside rear brake excessively fluctuating |3.7.B.3| | 4 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 4 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 4 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 4 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 4 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 4 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 4 |
| Nearside Headlamp insecure |1.7.3| | 4 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 4 |
| Nearside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 4 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 4 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 4 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 4 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 4 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 4 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 3 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 3 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 3 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 3 |
| Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b)) | 3 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Fuel system component leaking (6.1.3 (b) (i)) | 3 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 3 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 3 |
| Nearside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Offside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 3 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 3 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 3 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 3 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 3 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 3 |
| Rear Mechanical brake component has restricted free movement | 3 |
| Windscreen wiper blade insecure | 3 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 3 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 3 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 3 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 3 |
| Front brake disc in such a condition that it is seriously weakened | 3 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Offside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 3 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 3 |
| Offside Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Central Stop lamp|s| not working |4.3.1 |a| |ii|| | 3 |
| Upper Stop lamp not working |1.2.1b| | 3 |
| Offside Front Anti-roll bar linkage fractured |2.4.G.1| | 3 |
| Offside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 3 |
| Nearside Rear Outer Suspension spring mounting prescribed area is excessively corroded sill |2.4.A.3| | 3 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 3 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Brake pedal anti-slip provision worn smooth (1.1.2 (c)) | 2 |
| Offside Front Front drive shaft coupling flexible rubber or fabric coupling unit breaking up |2.5.C.1d| | 2 |
| Nearside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 2 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 2 |
| Rear brake binding | 2 |
| Steering rack insecure (2.1.3 (a) (i)) | 2 |
| Upper Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 2 |
| Nearside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill |7.1.1 |a| |i|| | 2 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 2 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 2 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 2 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Steering rack insecure |2.2.B.1a| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i)) | 2 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 2 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 2 |
| Central Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill (7.1.1 (a) (i)) | 2 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 2 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 2 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Spare wheel insecure |6.4.2| | 2 |
| Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 2 |
| Offside Rear Bumper damaged and likely to cause injury when grazed or contacted |6.1.4 |a| |i|| | 2 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 2 |
| Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 2 |
| Nearside Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 2 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Inner Front constant velocity joint is insecure |2.5.C.1b| | 2 |
| Offside Brake pipe leaking on a hydraulic braking system Front to rear (1.1.11 (b) (ii)) | 2 |
| Brake performance unable to be tested Brake pipe leaking (1.2.1 (g)) | 2 |
| Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Front Wheel bearing rough when rotated |5.1.3 |b| |i|| | 2 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Offside Rear Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 2 |
| Front Position lamp not working both |4.2.1 |a|| | 2 |
| Offside Front Position lamp not working |4.2.1 |a|| | 2 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 2 |
| Offside Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Headlamp lens seriously defective (4.1.1 (b) (ii)) | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 2 |
| Nearside Inner Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
| Offside rear brake juddering severely |3.7.A.5b| | 2 |
| Front Windscreen damaged and affecting the drivers view of the road cracked (3.2 (a) (ii)) | 2 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 2 |
| Offside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced outer sill (6.1.1 (c) (i)) | 2 |
| Offside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 2 |
| Offside Front Road wheel fixing missing |5.2.1 |a| |i|| | 2 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| rear brakes release unevenly |3.7.B.4| | 2 |
| Nearside Inner Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Central Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 2 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 2 |
| Offside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 2 |
| Bonnet primary retaining device ineffective (3.1 (c)) | 2 |
| Offside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Outer Suspension spring mounting prescribed area is excessively corroded sill |2.4.A.3| | 2 |
| Offside Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Emissions not tested |7.3.A.1| | 2 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Fuel tank leaking |7.2.3| | 2 |
| Rear brake disc in such a condition that it is seriously weakened | 2 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint likely to become detached (5.3.4 (a) (ii)) | 2 |
| Exhaust has a major leak of exhaust gases front of centre pipe |7.1.2| | 2 |
| Offside Front Anti-roll bar missing |2.4.G.1| | 2 |
| Offside Front Front constant velocity joint is insecure outer boot clip |2.5.C.1b| | 2 |