| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 14 |
| Registration plate lamp issues | 10 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Brake pipe excessively corroded | 9 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 6 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 3 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Nearside Rear Reversing lamp inoperative (4.6.1 (a)) | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Rear Reversing lamp inoperative |4.6.1 |a|| | 1 |
| Nearside Front Suspension arm pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
| Nearside Position lamp not working side marker (4.2.1 (a) (ii)) | 1 |
| Offside Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting Inner sil holed marked with yellow chalk (6.2.2 (d) (i)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front All outline marker lamps not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Leaf spring fractured 3rd leaf snapped (5.3.1 (b) (i)) | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Nearside Front Lower Outline marker lamp not working |4.2.1 |a| |ii|| | 1 |
| Offside Front Lower Outline marker lamp not working |4.2.1 |a| |ii|| | 1 |
| Offside Rear Bumper damaged and likely to cause injury when grazed or contacted (6.1.4 (a) (i)) | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Seat belt webbing significantly weakened (7.1.2 (b) (ii)) | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Rear Upper Outline marker lamp not working both (4.2.1 (a) (ii)) | 1 |
| Reversing lamp inoperative (4.6.1 (a)) | 1 |
| Offside Rear Anti-roll bar attachment bracket/mounting insecure (5.3.3 (a) (i)) | 1 |
| Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Offside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i)) | 1 |
| Reversing lamp inoperative |4.6.1 |a|| | 1 |
| Offside Front Inner Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt gaiter split (5.3.4 (b) (ii)) | 1 |
| Offside Front Brake hose excessively damaged hose cut and cords exposed (1.1.12 (b) (ii)) | 1 |
| Hazard warning switch inoperative ignition off |4.4.2 |a| |ii|| | 1 |
| All position lamps not working ignition off |4.2.1 |a|| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Exhaust emits an excessive level of metered smoke |7.4.B.3a| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front Lower Anti-roll bar linkage ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Nearside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Windscreen washer not working | 1 |
| Offside Outline marker lamp not working |4.2.1 |a|| | 1 |
| Offside Front Upper Outline marker lamp not working - led light unit not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Reversing lamp switch does not operate automatically when reverse gear is selected (4.6.3 (a)) | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Nearside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |