| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 76 |
| Registration plate lamp issues | 65 |
| Rear fog lamp not working |1.3.2b| | 35 |
| Headlamp aim out of alignment | 34 |
| Offside Stop lamp not working |1.2.1b| | 25 |
| Offside Rear fog lamp not working |1.3.2b| | 22 |
| Nearside Stop lamp not working |1.2.1b| | 22 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 21 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 17 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 17 |
| Brake pipe excessively corroded | 16 |
| Parking brake lever has no reserve travel |3.1.6b| | 14 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 13 |
| Horn not working |1.6.2a| | 13 |
| Rear fog lamp tell tale not working |1.3.1b| | 13 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 12 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 12 |
| Fuel system component leaking |7.2.3| | 12 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 12 |
| Rear parking brake recording little or no effort | 12 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 11 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 11 |
| Nearside Rear Anti-roll bar attachment bracket/mounting fractured |2.4.G.1| | 11 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 11 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 10 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 10 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 9 |
| Nearside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 9 |
| Parking brake: efficiency below requirements |3.7.B.7| | 9 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 8 |
| Anti-lock braking system warning lamp indicates an ABS fault | 8 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 8 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 8 |
| Offside Rear Stop lamp not working |1.2.1b| | 8 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 8 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 8 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 8 |
| Windscreen washer not working | 8 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 7 |
| Emissions not tested |7.0| | 7 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 7 |
| Service brake: efficiency below requirements |3.7.B.7| | 7 |
| Offside Rear fog lamp missing |1.3.2a| | 7 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 7 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 7 |
| Offside Headlamp not working on main beam |1.7.5a| | 7 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 6 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 6 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
| Nearside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 6 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 6 |
| Brakes imbalanced across an axle | 6 |
| Nearside Rear brake disc contaminated by oil |3.5.1h| | 5 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 5 |
| Battery insecure |1.9.1| | 5 |
| Nearside Rear Stop lamp not working |1.2.1b| | 5 |
| Power steering component|s| leaking |2.3.3b| | 5 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 5 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 5 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 5 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Offside Front Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 4 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 4 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 4 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 4 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 4 |
| Front brake excessively fluctuating | 4 |
| Offside Front front brake binding |3.7.B.1| | 4 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Horn not working (7.7 (a) (ii)) | 4 |
| Rear fog lamp emits a light other than red |1.3.2e| | 4 |
| Offside Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 4 |
| Windscreen has damage | 4 |
| Offside Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 4 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Rear fog lamp missing |1.3.2a| | 4 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 4 |
| Nearside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 4 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 4 |
| Registration plate issues | 4 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 4 |
| Front brake disc in such a condition that it is seriously weakened | 4 |
| Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Nearside Front Anti-roll bar ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
| Rear Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 3 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 3 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 3 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 3 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 3 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 3 |
| Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Offside Rear Anti-roll bar attachment bracket/mounting cracked |2.4.G.1| | 3 |
| Nearside Rear Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 3 |
| Offside Rear Anti-roll bar attachment bracket/mounting insecure |2.4.G.1| | 3 |
| Nearside Front Anti-roll bar ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
| Nearside Front Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 3 |
| Rear fog lamp insecure |1.3.2a| | 3 |
| Nearside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 3 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 3 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 3 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 3 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 3 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 3 |
| Offside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 3 |
| Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 3 |
| Front brake disc excessively pitted |3.5.1h| | 2 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 2 |
| Offside Headlamp aim not tested |1.8.A.1c| | 2 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 2 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 2 |
| Nearside Rear Anti-roll bar insecure |2.4.G.1| | 2 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement D bush |2.4.G.2| | 2 |
| Offside Front Subframe mounting prescribed area is excessively corroded crossmember |2.4.A.3| | 2 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill |5.3.6 |a| |i|| | 2 |
| Offside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Front Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded outer sill |2.4.A.3| | 2 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded inner sill |2.4.A.3| | 2 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 2 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Rear Body has a projection caused by corrosion |6.1.C.1| | 2 |
| Offside Front Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 2 |
| Rear fog lamp switch missing |1.3.1a| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Nearside Front front brake binding |3.7.B.1| | 2 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 2 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 2 |
| Service brake: efficiency below requirements |3.7.C.1a| | 2 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Front Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 2 |
| Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values (8.2.2.2 (f)) | 2 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Rear Anti-roll bar attachment bracket/mounting fractured (5.3.3 (b) (ii)) | 2 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 2 |
| Offside Front Position lamp not working |4.2.1 |a|| | 2 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 2 |
| Offside Rear fog lamp missing |4.5.1 |a| |ii|| | 2 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Rear Rear fog lamp missing |1.3.2a| | 2 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Nearside Front Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 2 |
| Offside Rear Lower Rear fog lamp missing |1.3.2a| | 2 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Horn not working |7.7 |a| |ii|| | 2 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 2 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 2 |
| Offside Front Battery insecure |1.9.1| | 2 |
| Offside Rear Anti-roll bar attachment bracket/mounting damaged and its strength is seriously reduced |2.4.G.1| | 2 |
| Offside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Outer Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Nearside Front Anti-roll bar linkage insecure |2.4.G.1| | 2 |
| Nearside Outer Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Outer Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Inner Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Outer Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Inner Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Mechanical brake component has restricted free movement | 2 |
| Offside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill |7.1.1 |a| |i|| | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Exhaust has a part missing |7.1.1a| | 2 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Rear Anti-roll bar linkage insecure |2.4.G.1| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Nearside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 2 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 2 |
| Offside Front Shock absorbers has a serious fluid leak | 2 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 2 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |