| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 11 |
| Brake pipe excessively corroded | 6 |
| Headlamp aim out of alignment | 5 |
| Windscreen wiper does not clear the windscreen effectively | 5 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 3 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Offside Rear Service brake excessively fluctuating (1.2.1 (e)) | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Nearside Rear Leaf spring main leaf fractured (5.3.1 (b) (ii)) | 2 |
| Nearside Stop lamp emits other than a steady red light dim |1.2.1e| | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Upper Outline marker lamp not working cab |4.2.1 |a|| | 1 |
| Offside Front Upper Outline marker lamp not working cab |4.2.1 |a|| | 1 |
| Nearside Rear Lower Anti-roll bar linkage pin or bush excessively worn link arm |5.3.4 |a| |i|| | 1 |
| Offside Rear Lower Anti-roll bar linkage pin or bush excessively worn link arm |5.3.4 |a| |i|| | 1 |
| Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Brakes imbalanced across an axle | 1 |
| Offside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Entrance/exit door defective in operation sliding door unable to open from outside |9.1.1 |a|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Rear Leaf spring fractured (5.3.1 (b) (i)) | 1 |
| Nearside Rear All outline marker lamps not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Hazard warning switch inoperative not working when ignition off |4.4.2 |a| |ii|| | 1 |
| Nearside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front position lamp|s| not working side light |1.1.A.3b| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front position lamp|s| not working side light |1.1.A.3b| | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Brake pipe connection leaking on a hydraulic braking system FLEXI TO PIPE JOINT (1.1.11 (b) (ii)) | 1 |
| Offside Front Outer Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced SILL HOLED (6.1.1 (c) (i)) | 1 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Position lamp not working both fronts (4.2.1 (a) (ii)) | 1 |
| Nearside Rear position lamp|s| not working side light |1.1.A.3b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Leaf spring main leaf fractured (5.3.1 (b) (ii)) | 1 |
| Offside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Windscreen washer not working | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement rear wishbone bush |2.4.G.2| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Rear Brake disc significantly and obviously worn |1.1.14 |a| |i|| | 1 |
| Offside Rear Brake cable has restricted free movement cable not returning fully - freed off (1.1.15 (e)) | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Upper Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Reversing lamp inoperative (4.6.1 (a)) | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Upper Stop lamp not working |1.2.1b| | 1 |