| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 12 |
| Parking brake: efficiency below requirements |3.7.B.7| | 10 |
| Horn not working |1.6.2a| | 4 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Registration plate lamp issues | 4 |
| Brakes imbalanced across an axle | 4 |
| Exhaust system not adequately supported |7.1.1| | 4 |
| Brake pipe excessively corroded | 3 |
| Windscreen washer not working | 3 |
| Nearside Headlamp not working on main beam |1.7.5a| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Registration plate issues | 3 |
| Offside Front front brake binding |3.7.B.1| | 3 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Brake hose excessively deteriorated | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 2 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 2 |
| Centre Exhaust system not adequately supported |7.1.1| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Rear Seat belt anchorage loose (7.1.1 (b)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner/Outer sill (5.3.6 (a) (i)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Windscreen has damage | 1 |
| Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Rear Lower Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced marked yellow (6.1.1 (c) (i)) | 1 |
| Nearside Front Suspension arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Suspension arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Suspension arm synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear Suspension component mounting prescribed area is deliberately modified which significantly reduces the original strength |2.4.A.3| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill/floor in front of rear wheel |6.1.B.2| | 1 |
| Nearside Headlamp aim so that beam "kick up" is not visible on the screen kick up the wrong way |1.8.B.1| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings outer sill |6.1.B.2| | 1 |
| Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Offside Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Battery insecure |1.9.1| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Exhaust emissions carbon monoxide content excessive 11.2% |8.2.1.2 |b|| | 1 |
| Offside Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Nearside Front Fuel pipe leaking |7.2.3| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Horn sounds harsh or grating |1.6.2e| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Inner Rear Lower Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |