| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 24 |
| Headlamp aim out of alignment | 23 |
| Windscreen wiper does not clear the windscreen effectively | 14 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 13 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 13 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Service brake: efficiency below requirements |3.7.B.7| | 7 |
| Registration plate lamp issues | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Brakes imbalanced across an axle | 4 |
| Horn not working |1.6.2a| | 4 |
| Windscreen washer not working | 4 |
| Brake hose excessively deteriorated | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Rear brake binding | 3 |
| Rear parking brake recording little or no effort | 3 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Brake pipe leaking |3.6.A.1| | 2 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 2 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Front Position lamp not working |4.2.1 |a|| | 2 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 2 |
| Nearside Front Shock absorbers has a serious fluid leak | 2 |
| Exhaust system insecure (6.1.2 (a)) | 2 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Power steering component|s| leaking |2.3.3b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 2 |
| Horn not working (7.7 (a)) | 2 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Rear Position lamp adversely affected by the operation of another lamp both sides |4.2.3 |c|| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Front brake excessively fluctuating | 1 |
| Central Front Vehicle structure is fractured and structural rigidity is significantly reduced radiator cross member corroded (6.1.1 (a) (i)) | 1 |
| Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Offside Body has a projection caused by damage |step jammed out| |6.1.C.1| | 1 |
| Offside Front Lower Brake hose excessively stretched (1.1.12 (b) (ii)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Brake pedal creeps down while the pedal is held under pressure |3.3.B.1a| | 1 |
| Brake pedal reservoir fluid level decreases after several brake applications |3.3.C.1| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Brake hose damaged | 1 |
| Nearside Front Inner Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside front brake binding |3.7.B.1| | 1 |
| Battery insecure |1.9.1| | 1 |
| Fuel system component leaking (6.1.3 (b) (i)) | 1 |
| Nearside Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Nearside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Registration plate issues | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Outer Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear Leaf spring to axle securing nut insecure |2.4.B.7b| | 1 |
| Nearside Rear Leaf spring damaged and permanently distorted |2.4.B.1a| | 1 |
| Offside Rear Leaf spring damaged and permanently distorted |2.4.B.1a| | 1 |
| Nearside Rear Air suspension unit totally deflated |2.4.D.1a| | 1 |
| Offside Rear Air suspension unit totally deflated |2.4.D.1a| | 1 |
| Nearside Rear Air suspension unit supply pipe damaged and seriously weakened |2.4.D.3| | 1 |
| Offside Rear Air suspension unit supply pipe damaged and seriously weakened |2.4.D.3| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Trailer electrical socket (13 pin) not operating the trailer lamps as intended when fog light switched on reverse light illuminates on trailer board (4.10 (c) (i)) | 1 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Offside Front Passengers seat backrest cannot be secured in the upright position. (6.2.6 (a) (i)) | 1 |
| Fluid leak harmful to the environment or a risk to other road users coolant leaking (8.4.1 (a) (i)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Emissions not tested due to coolant leak and exhaust gas leak (8.2.2.2 (e)) | 1 |
| Brake load sensing valve seized but ABS functioning (1.1.17 (c) (i)) | 1 |
| Rear Brake cable insecure | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Rear Leaf spring cracked |2.4.B.1a| | 1 |
| Nearside Rear Leaf spring fractured (5.3.1 (b) (i)) | 1 |
| Offside Rear Leaf spring fractured (5.3.1 (b) (i)) | 1 |
| Rear fog lamp adversely affected by the operation of another lamp (4.5.4 (b)) | 1 |
| Nearside Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Nearside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Hazard warning switch insecure |1.4.B.1d| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Braking system leaking |3.6.A.1| | 1 |
| Offside front brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Power steering inoperative |2.3.3a| | 1 |
| Power steering pipe|s| or hose|s| leaking pipe across rack |2.3.3b| | 1 |
| Offside Front Seat belt damaged sufficient to significantly weakened the webbing |5.2.2a| | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Offside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Central Front Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Offside Front Power steering pipe/hose leaking Leaking unions at rack (2.1.5 (a)) | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Offside Headlamp aim beam image too far to the right |1.6.B4| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Headlamp aim so that beam "kick up" is not visible on the screen (4.1.2 (a)) | 1 |
| Exhaust emissions exceed level of metered smoke for a non-turbo charged engine (8.2.2.2 (b)) | 1 |
| Central Exhaust system insecure (6.1.2 (a)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Stop lamp not working (1.2.1b) | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Fuel system component leaking pump area |7.2.3| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Sub mount |6.1.B.2| | 1 |
| Brake hose has insufficient room to move | 1 |
| Power steering component|s| leaking rack |2.3.3b| | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Brake cable insecure |3.5.1d| | 1 |
| Steering rack insecure |2.2.B.1a| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Driver`s view of the road through the swept area of the windscreen materially affected by an obstruction |3.1 |a| |ii|| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Front Fuel pipe leaking (6.1.3 (b) (i)) | 1 |
| Central Exhaust has a major leak of exhaust gases pipe (6.1.2 (a)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced next to jacking point (6.1.1 (c) (i)) | 1 |
| Nearside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Fuel hose leaking leak off pipes on the injectors (6.1.3 (b) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner arch to strut top (5.3.6 (a) (i)) | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Front Windscreen wiper not working (3.4 (a)) | 1 |
| Offside Rear Seat belt webbing significantly weakened cut from edge greater than 2mm (7.1.2 (b)) | 1 |