| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 12 |
| Headlamp aim out of alignment | 9 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 3 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 3 |
| Front brake excessively fluctuating | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Brakes imbalanced across an axle | 2 |
| Front brake application uneven | 2 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Horn not working |1.6.2a| | 2 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 2 |
| Rear brake binding | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 2 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 2 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Headlamp aim not tested |1.8.A.1c| | 1 |
| Nearside Front Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting x/member |6.2.2 |d| |i|| | 1 |
| Offside Front Electrical wiring likely to touch hot or rotating parts |4.11 |a| |iii|| | 1 |
| Offside Rear Electrical wiring likely to touch hot or rotating parts |4.11 |a| |iii|| | 1 |
| Nearside Front Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Offside Front Service brake effort inadequate at a wheel |1.2.1 |a| |i|| | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Brake linkage has restricted free movement (1.1.15 (e)) | 1 |
| Nearside Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Offside Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Offside Rear Direction indicator incorrect colour shows white |1.4.A.2f| | 1 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Power steering component|s| leaking from rack area |2.3.3b| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded upper wheel arch |2.4.A.3| | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Rear parking brake recording little or no effort | 1 |
| Rear Parking (secondary brake) on a single line braking system grabbing severely (1.3.1 (c)) | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wing (5.3.6 (a) (i)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced within 12inch of engine /transmission mount (6.1.1 (c) (i)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Windscreen in an unacceptable condition cracked (3.2 (c) (i)) | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced jacking point (6.1.1 (c) (i)) | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Front Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Rear Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Step (6.1.1 (c) (i)) | 1 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced front crossmember (6.1.1 (c) (i)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Parking brake lever, pawl mechanism pivots or their associated mountings are insecure |3.1.4b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Registration plate lamp issues | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Front Upper Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Bonnet cannot be secured in the closed position (3.1 (b) (i)) | 1 |
| Nearside Lower Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced arch to cill (6.1.1 (c) (i)) | 1 |
| Offside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced arch to cill (6.1.1 (c) (i)) | 1 |
| Nearside Rear Stop lamp|s| light intensity significantly reduced |4.3.3 |a| |ii|| | 1 |
| Nearside Rear Position lamp light intensity significantly reduced |4.2.3 |a| |ii|| | 1 |
| Nearside Rear Leaf spring linkage pin excessively loose in its bracket front most |2.4.B.3a| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Nearside Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |