| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 16 |
| Windscreen wiper does not clear the windscreen effectively | 14 |
| Brakes imbalanced across an axle | 9 |
| Registration plate lamp issues | 6 |
| Registration plate issues | 6 |
| Offside Stop lamp not working |1.2.1b| | 4 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 4 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Horn not working |1.6.2a| | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill (6.1.1 (c) (i)) | 2 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 2 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill (6.1.1 (c) (i)) | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Windscreen washer not working | 2 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Rear Service brake lagging in operation (1.2.1 (d)) | 2 |
| Rear brake binding | 2 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced Subframe pick up area (6.1.1 (c) (i)) | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength holed by jacking point (5.3.6 (a) (i)) | 1 |
| Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength arch (5.3.6 (a) (i)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush likely to become detached link rod broken (5.3.4 (a) (ii)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Emissions unable to be completed oil level low (8.2.2.2 (e)) | 1 |
| Nearside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength strut leg turret (see chalk mark) (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength strut leg turret (see chalk mark) (5.3.6 (a) (i)) | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside rear brakes release unevenly |3.7.B.4| | 1 |
| Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Trailer electrical socket |13 pin| not operating the trailer lamps as intended |1.9.4| | 1 |
| Passenger`s seat insecure Bolt missing |6.2.A.1| | 1 |
| Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Exhaust mounting missing |7.1.1b| | 1 |
| Front Exhaust mounting missing |7.1.1b| | 1 |
| Offside Rear Lower Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Suspension rod ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Drivers seat moving inadvertently (6.2.5 (b) (ii)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Shock absorbers has a serious fluid leak | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 1 |
| Stop lamp(s) all not working rears (4.3.1 (a) (iii)) | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Front brake excessively fluctuating | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Front Service brake excessively fluctuating both (1.2.1 (e)) | 1 |
| Front Brake disc significantly and obviously worn both (1.1.14 (a) (i)) | 1 |
| Nearside Rear front brake binding |3.7.B.1| | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |