| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 32 |
| Headlamp aim out of alignment | 23 |
| Brake pipe excessively corroded | 22 |
| Registration plate lamp issues | 12 |
| Brakes imbalanced across an axle | 10 |
| Horn not working |1.6.2a| | 8 |
| Windscreen washer not working | 5 |
| Rear brake binding | 5 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 5 |
| Horn not working (7.7 (a)) | 4 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 4 |
| Parking brake: efficiency below requirements |3.7.B.7| | 4 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 4 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Registration plate issues | 3 |
| Front brake disc in such a condition that it is seriously weakened | 3 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 3 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 3 |
| Horn not working |7.7 |a| |ii|| | 3 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 2 |
| Rear Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Horn not working (7.7 (a) (ii)) | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Rear brake application uneven | 2 |
| Front brake application uneven | 2 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Front Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 2 |
| Nearside Front Side repeater not working |1.4.A.2c| | 2 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 2 |
| Battery insecure and likely to fall from carrier |4.13 |a| |ii|| | 2 |
| Front brake excessively fluctuating | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Exhaust mounting missing |7.1.1b| | 2 |
| Nearside Front front brake binding |3.7.B.1| | 2 |
| Nearside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Front Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill back (5.3.6 (a) (i)) | 1 |
| Offside Rear Coil spring mounting insecure (5.3.1 (a) (i)) | 1 |
| Offside Brake cable insecure Cable pulled through cable stay (1.1.15 (c)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Lower Chassis by radiatior X member (5.3.6 (a) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting chassis rail (6.2.2 (d) (i)) | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting jacking point (inside) (6.2.2 (d) (i)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting jacking point (outside) (6.2.2 (d) (i)) | 1 |
| Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting jacking point (inside) (6.2.2 (d) (i)) | 1 |
| Offside Brake cable insecure (1.1.15 (c)) | 1 |
| Brake hose damaged | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Front Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Electrical wiring insecure and in contact with sharp edges near battery (4.11 (a) (ii)) | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Front Outline marker lamp not working |4.2.1 |a| |ii|| | 1 |
| Nearside Front Brake hose leaking on a hydraulic braking system |1.1.12 |c| |ii|| | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Upper Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Lower Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Front Power steering component|s| leaking |2.3.3b| | 1 |
| rear brakes release unevenly |3.7.B.4| | 1 |
| Nearside Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Rear Rear fog lamp insecure |1.3.2a| | 1 |
| Offside Rear Rear fog lamp flickers when tapped lightly by hand |1.1.6d| | 1 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Nearside Rear Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Headlamp levelling device inoperative (4.1.5 (a)) | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Headlamp aim unable to be tested (4.1.2 (b)) | 1 |
| Nearside Rear Upper Outline marker lamp missing (4.2.1 (a) (ii)) | 1 |
| Nearside Front Lower Outline marker lamp missing (4.2.1 (a) (ii)) | 1 |
| Undertray likely to become detached refit (6.2.1 (a) (ii)) | 1 |
| Offside Front Inner Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected Inner wing/wheel arch section (5.3.6 (a) (ii)) | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Front Shock absorbers has negligible damping effect (5.3.2 (d)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Brake pedal anti-slip provision loose refit |3.3.A.1b| | 1 |
| Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill |7.1.1 |a| |i|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill |7.1.1 |a| |i|| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill |7.1.1 |a| |i|| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner arch |5.3.6 |a| |i|| | 1 |
| Nearside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength inner arch |5.3.6 |a| |i|| | 1 |
| Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength inner arch |5.3.6 |a| |i|| | 1 |
| Nearside Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Direction indicators adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Nearside Front Suspension component ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Offside Rear Brake hose twisted |3.6.B.4c| | 1 |
| Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Offside Front Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Central Rear Stop lamp|s| with a multiple light source more than 1/2 not functioning |4.3.1 |a| |ii|| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Offside Front Electrical wiring insecure and in contact with sharp edges next to battery |4.11 |a| |ii|| | 1 |
| Rear Brake load sensing valve seized |3.6.E.3| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Rear Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Braking system leaking hub |3.6.A.1| | 1 |
| Nearside Rear Shock absorber detached middle axel |2.7.2b| | 1 |
| Nearside Rear Hydraulic brake cylinder leaking and braking performance affected (1.1.16 (b) (ii)) | 1 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Lower Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Chassis (front leg) corroded to excess (6.1.1 (c) (i)) | 1 |
| Nearside Front Lower Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced suspension turret (6.1.1 (c) (i)) | 1 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Outer Front Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Rear Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner wheel arch |6.2.2 |d| |i|| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner wing next to chassis leg |6.2.2 |d| |i|| | 1 |
| Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting bottom of chassis leg next to bottom cross member |6.2.2 |d| |i|| | 1 |
| Offside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Rear Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Offside Front Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting AREA AT SUB-FRAME MOUNTING (6.2.2 (d) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced INNER WHEELARCH CORRODED & HOLED (6.1.1 (c) (i)) | 1 |
| Nearside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Parking brake recording little or no effort |3.7.D.3a| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |