| Most common failures | No# failures |
|---|
| Service brake: efficiency below requirements |3.7.B.7| | 6 |
| Headlamp aim out of alignment | 5 |
| Brake pipe excessively corroded | 4 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 4 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Exhaust system not adequately supported |7.1.1| | 3 |
| Brakes imbalanced across an axle | 2 |
| Registration plate issues | 2 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Windscreen washer not working | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Exhaust system insecure |6.1.2 |a|| | 1 |
| Offside Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Front passenger seat insecure |6.2.3| | 1 |
| Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Registration plate lamp issues | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear Suspension component mounting prescribed area is fractured |2.4.A.3| | 1 |
| Nearside Rear Air suspension accumulator damaged and likely to fail |2.4.D.1b| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Offside Rear brake drum contaminated by brake fluid |3.5.1h| | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Offside Front Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Front Fuel system component leaking (6.1.3 (b) (i)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Rear Parking |secondary brake| on a single line braking system has no recorded effort at a wheel |1.3.1 |a| |ii|| | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases front pipe split and cracked (6.1.2 (a)) | 1 |
| Emissions not tested not tested due to exhaust front pipe condition (8.2.2.2 (e)) | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Parking brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Headlamp not working on dipped beam water ingress in headlight (4.1.1 (a) (ii)) | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear parking brake recording little or no effort | 1 |
| Nearside Front Headlamp lens missing (4.1.1 (b) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Exhaust emissions exceed level of metered smoke for a non-turbo charged engine (8.2.2.2 (b)) | 1 |
| Offside Front Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm likely to become detached INSECURE (5.3.3 (a) (ii)) | 1 |