| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 34 |
| Windscreen wiper does not clear the windscreen effectively | 18 |
| Headlamp aim out of alignment | 14 |
| Rear brake binding | 12 |
| Registration plate lamp issues | 11 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 7 |
| Windscreen washer not working | 7 |
| Nearside Side repeater not working |1.4.A.2c| | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 6 |
| Brakes imbalanced across an axle | 6 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Offside Side repeater not working |1.4.A.2c| | 5 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 4 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Horn not working |1.6.2a| | 3 |
| Battery insecure |1.9.1| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Centre Front Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Headlamp aim beam image kick up to the offside |1.8| | 3 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Brake hose excessively deteriorated | 2 |
| Offside Rear Brake cable locking device insecure |3.5.1l| | 2 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
| Offside Front Side repeater not working |1.4.A.2c| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Fuel system component leaking |7.2.3| | 2 |
| Offside All position lamps not working |1.1.A.3b| | 2 |
| Horn not working (7.7 (a)) | 2 |
| Rear parking brake recording little or no effort | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Rear Passengers seat insecure seat not locking in position and can swivel freely (6.2.6 (a) (ii)) | 1 |
| Nearside Front Side repeater missing |1.4.A.2b| | 1 |
| Offside Front Side repeater missing |1.4.A.2b| | 1 |
| Offside Rear Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Headlamp aim projected beam image is obviously incorrect Kick up to the offside, both lamps (4.1.2 (c)) | 1 |
| Emissions not tested Exhaust broken (8.2.2.2 (e)) | 1 |
| Nearside Rear Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Nearside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Offside Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Brake lever has abnormal movement of levers indicating maladjustment |3.5.1f| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement rear bush |2.4.G.2| | 1 |
| Nearside Front Electrical wiring damaged, likely to cause a short fog light wiring |1.9.2b| | 1 |
| Offside Lower Front suspension has excessive play in an outer ball joint |2.5.B.2a| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Registration plate issues | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Brake load sensing valve linkage defective and function impaired (1.1.17 (a)) | 1 |
| Centre Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Side repeater insecure |1.4.A.2b| | 1 |
| Rear brake application uneven | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Rear fog lamp obviously incorrectly positioned (4.5.4 (a)) | 1 |
| Offside Front Outer Prop shaft joint constant velocity boot no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Lower Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced cross member (6.1.1 (c) (i)) | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced cross member (6.1.1 (c) (i)) | 1 |
| Offside Front Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i)) | 1 |
| Offside Front Upper Power steering component leaking (2.1.5 (a)) | 1 |
| Nearside Front Lower Bumper insecure (6.1.4 (a) (i)) | 1 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Brake cable locking device insecure |3.5.1l| | 1 |
| Offside Rear All position lamps not working side marker light |1.1.A.3b| | 1 |
| Nearside Rear Wheel bearing play so excessive it is likely to break up |5.1.3 |a| |ii|| | 1 |
| Offside Rear Wheel bearing so rough it is likely to overheat or break up |5.1.3 |b| |ii|| | 1 |
| Offside Rear Leaf spring seriously weakened |5.3.1 |b| |i|| | 1 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded crossmember |2.4.A.3| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength jacking point |5.3.6 |a| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength jacking point |5.3.6 |a| |i|| | 1 |
| Exhaust system insecure |6.1.2 |a|| | 1 |
| Nearside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Suspension component mounting prescribed area is excessively corroded inner wing |2.4.A.3| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Rear Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Offside Rear Suspension has inadequate clearance with the bump stop |2.4.A.1a| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Central Exhaust system insecure |6.1.2 |a|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength jack point (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Front Seat belt affected by an insecure seat fixing |5.2.1b| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Side repeater excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
| Offside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Front Upper Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Suspension spring mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected |5.3.6 |a| |ii|| | 1 |
| Offside Front Suspension spring mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected |5.3.6 |a| |ii|| | 1 |
| Offside Front Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill |7.1.1 |a| |i|| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Headlamp light intensity severely reduced dip beam &main beam (bad connection at electrical plug to bulb) (4.1.4 (a)) | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Front Service brake lagging in operation |1.2.1 |d|| | 1 |
| Nearside Rear Position lamp not working Only 50% working |4.2.1 |a|| | 1 |
| Offside Rear Service brake excessively binding Parking brake cable not returning fully |1.2.1 |f|| | 1 |
| Brake performance not tested |1.2.1 |g|| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced sill inadequate repair |7.1.1 |a| |i|| | 1 |
| Offside Rear fog lamp obviously incorrectly positioned |1.3.2a| | 1 |
| Offside Inner Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Nearside Outer Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Outer Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Nearside Rear Outer Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Front Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Front Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Centre All position lamps not working |1.1.A.3b| | 1 |
| Nearside Rear All position lamps not working |1.1.A.3b| | 1 |
| Centre Exhaust mounting missing |7.1.1b| | 1 |
| Exhaust has a major leak of exhaust gases silencer (6.1.2 (a)) | 1 |
| Nearside Rear Service brake lagging in operation (1.2.1 (d)) | 1 |
| Nearside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength highlighted (5.3.6 (a) (i)) | 1 |
| Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis (highlighted) (6.1.1 (c) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Offside Rear Brake cable has wires broken and is significantly weakened |3.5.1b| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area is corroded to the extent that control of the vehicle is likely to be adversely affected CROSS MEMBER |5.3.6 |a| |ii|| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Brake load sensing valve seized and ABS not fitted or inoperative |1.1.17 |c| |ii|| | 1 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Rear Brake cable insecure | 1 |
| Offside Rear Upper Position lamp showing white light to the rear (4.2.3 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering chassis leg |6.1.A.1| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside All position lamps not working |1.1.A.3b| | 1 |
| Offside Headlamp has a product on the light source so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Steering system excessively tight |2.2.D.1| | 1 |
| Nearside Front Brake pipe leaking on a hydraulic braking system to rear |1.1.11 |b| |ii|| | 1 |
| Offside Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Headlamp aim not tested (4.1.2 (b)) | 1 |
| Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b)) | 1 |
| Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced jacking point /out rigger (6.1.1 (c) (i)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced jacking point /out rigger (6.1.1 (c) (i)) | 1 |
| Fuel system component leaking (6.1.3 (b) (i)) | 1 |
| Nearside Rear Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Side repeater lens defective such that the emitted light is adversely affected (4.4.1 (b) (ii)) | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |