| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 20 |
| Windscreen wiper does not clear the windscreen effectively | 10 |
| Brake pipe excessively corroded | 9 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 4 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Windscreen washer not working | 4 |
| Brakes imbalanced across an axle | 4 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 4 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 4 |
| Registration plate lamp issues | 3 |
| Oil leaking excessively from engine |8.4.1 |a| |i|| | 3 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Front Headlamp insecure |1.7.3| | 2 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Nearside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 2 |
| Offside Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Rear Upper Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Rear brake binding | 2 |
| Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Centre Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Headlamp insecure |1.7.3| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Exhaust emits an excessive level of metered smoke for a non-turbo charged engine |7.4.B.3b| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Offside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Offside Front Stop lamp not working |1.2.1b| | 1 |
| Offside Front Lower Suspension arm attachment bracket/mounting bolt missing |2.4.G.1| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Rear Brake cable has restricted free movement |3.5.1k| | 1 |
| Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Rear Suspension spring mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Nearside Headlamp insecure |1.7.3| | 1 |
| Nearside Outer Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings out riger |6.1.B.2| | 1 |
| Offside Front Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings wheel arch |6.1.B.2| | 1 |
| Nearside Front Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings wheel arch |6.1.B.2| | 1 |
| Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Rear Leaf spring has excessive side play at eye |shackle| |2.4.B.4| | 1 |
| Offside Rear Leaf spring has excessive side play at eye |shackle| |2.4.B.4| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear coil spring fractured |2.4.C.1a| | 1 |
| Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Offside Front Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Offside Front Upper Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Fuel tank leaking |7.2.3| | 1 |
| Nearside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |6.1.B.2| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Lower Headlamp insecure |1.7.3| | 1 |
| Nearside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Electrical wiring connectors for braking disconnected (4.11 (a) (iii)) | 1 |
| Offside Rear Valve stem seriously damaged split and perished (5.2.3 (j)) | 1 |
| Nearside Rear Leaf spring shackle pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Leaf spring shackle pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Rear brake application uneven | 1 |
| Nearside Body component damaged and likely to cause injury Hook up socket metal cover jutting out (6.2.1 (a) (i)) | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Exhaust system insecure MOUNTINGS BROKEN (6.1.2 (a)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Headlamp aim beam image kick up to the offside also beam image too low |1.8| | 1 |
| Front Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
| Offside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
| Nearside Driver`s seat insecure |6.2.A.1| | 1 |
| Bonnet cannot be secured in the closed position |8.4.1| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Outer Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Rear fog lamp does not face the rear |4.5.4 |a|| | 1 |
| Fuel system component leaking excessively or a risk of fire front of engine |6.1.3 |b| |ii|| | 1 |
| Engine mounting damaged or deteriorated resulting in excessive movement central lower |6.1.8 |a| |i|| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Windscreen has damage | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Suspension component mounting prescribed area fractured significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area is inadequately repaired X2 (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength very rear upper X2 (5.3.6 (a) (i)) | 1 |
| Offside Rear Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases center box (6.1.2 (a)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Brake load sensing valve seized |3.6.E.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded inner wing |2.4.A.3| | 1 |
| Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Windscreen wiper blade insecure | 1 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front brake disc contaminated by oil |3.5.1h| | 1 |
| Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Steering system excessively rough |2.2.D.1| | 1 |
| Exhaust emissions exceed manufacturer`s specified limit |8.2.2.2 |a|| | 1 |
| Nearside Headlamp light intensity severely reduced |4.1.4 |a|| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
| Headlamp aim beam image kick up to the offside both |1.8| | 1 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Front Headlamp aim beam image kick up to the offside Both |1.8| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Outer Parking brake mechanism/associated mounting prescribed area is excessively corroded sill (1.1.21 (e) (i)) | 1 |
| Nearside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Nearside Front Road wheel fixing loose (5.2.1 (a) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wheel arch (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.A.3| | 1 |
| Central Front Suspension component mounting prescribed area is excessively corroded cross member |2.4.A.3| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Front passenger door cannot be opened from inside the vehicle |6.2.3 |a|| | 1 |
| Nearside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |