| Most common failures | No# failures |
|---|
| Registration plate issues | 82 |
| Headlamp aim out of alignment | 35 |
| Windscreen wiper does not clear the windscreen effectively | 20 |
| Parking brake: efficiency below requirements |3.7.B.7| | 14 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 8 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 7 |
| Offside Front Shock absorbers has a serious fluid leak | 7 |
| Offside Rear Shock absorbers has a serious fluid leak | 7 |
| Nearside Front Shock absorbers has a serious fluid leak | 7 |
| Nearside Rear Shock absorbers has a serious fluid leak | 6 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 5 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 4 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 4 |
| Brakes imbalanced across an axle | 4 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Horn not working |1.6.2a| | 3 |
| Rear brake binding | 3 |
| Rear parking brake recording little or no effort | 3 |
| Horn not working (7.7 (a) (ii)) | 3 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 2 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 2 |
| Dipswitch does not operate immediately when selected on main beam (4.1.3 (b)) | 2 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 2 |
| Nearside Rear Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
| Windscreen washer not working | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 2 |
| Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Electronic parking brake warning indicates a malfunction |3.1.7| | 2 |
| Registration plate lamp issues | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Main beam tell-tale not working (4.9.1 (a) (ii)) | 2 |
| Windscreen has damage | 2 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Nearside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Electronic stability control warning lamp indicates a fault |7.12 |e|| | 1 |
| Nearside Front Road wheel cracked |4.2.A.1a| | 1 |
| Offside Front Shock absorber casing damaged externally so the unit does not function |2.7.2a| | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Brake pipe leaking on a hydraulic braking system ridged to flex joint leaking (1.1.11 (b) (ii)) | 1 |
| Brake performance not tested fluid leak (1.2.1 (g)) | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Nearside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Brake performance not tested front spring broken and sitting down on shock absorber |1.2.1 |g|| | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Offside Rear Brake disc insecure (1.1.14 (a) (ii)) | 1 |
| Brake pipe excessively corroded | 1 |
| Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Horn not working (7.7 (a)) | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Headlamp cleaning device inoperative |1.7.2| | 1 |
| Front Headlamp not working on main beam may be switch (4.1.1 (a) (ii)) | 1 |
| Offside Front Inner Road wheel badly distorted (5.2.2 (c) (i)) | 1 |
| Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Seat belt stitching badly frayed |5.2.2b| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Front Stop lamp not working |1.2.1b| | 1 |
| Front Inner Anti-roll bar pin or bush excessively worn both a/roll bar "D" bushes worn o/side and n/side (5.3.4 (a) (i)) | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Nearside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Service brake excessively fluctuating |1.2.1 |e|| | 1 |
| Nearside Front Inner Road wheel fractured flat spot/cracked (5.2.2 (a)) | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Rear Seat belt retracting mechanism defective (7.1.2 (e)) | 1 |
| Offside Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Dipswitch does not operate immediately when selected on main beam |4.1.3 |b|| | 1 |
| Electronic parking brake control defective so that it cannot be satisfactorily operated (1.1.6 (d)) | 1 |
| Nearside Direction indicator not working Side repeater (4.4.1 (a) (ii)) | 1 |
| Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Windscreen wiper not working |3.4 |a|| | 1 |
| Nearside Rear Lower Suspension arm has excessive play in a pin/bush outer rose jiont |2.4.G.2| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Headlamp does not operate immediately when selected on main beam |1.7.4a| | 1 |
| Electronic parking brake control defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Nearside Obligatory mirror missing |8.1.1| | 1 |
| Offside Front Brake hose excessively damaged |3.6.B.4d| | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Inner Drag link end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Tie bar/rod has excessive play in a ball joint pin or bush |2.4.G.2| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Rear Lower Suspension arm pin or bush excessively worn wishbone/hub bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Lower Suspension arm pin or bush excessively worn wishbone/hub bush (5.3.4 (a) (i)) | 1 |
| Nearside Rear Suspension rod ball joint dust cover no longer prevents the ingress of dirt track rod arm |5.3.4 |b| |ii|| | 1 |
| Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Inner Steering linkage ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Shock absorbers damaged to the extent that it does not function (5.3.2 (b)) | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Headlamp cleaning device for LED or HID headlamp inoperative (4.1.6 (a) (ii)) | 1 |
| Battery insecure |1.9.1| | 1 |
| Headlamp aim so that beam "kick up" is not visible on the screen both. |4.1.2 |a|| | 1 |
| Central Stop lamp(s) with a multiple light source more than 1/2 not functioning (4.3.1 (a) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Offside Front Gas suspension unit leaking |2.4.D.2| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Rear brake application uneven | 1 |
| Nearside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Front Anti-roll bar rubber bush deteriorated resulting in excessive movement n.s & o.s |2.4.G.2| | 1 |
| Offside Rear Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |