| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 50 |
| Headlamp aim out of alignment | 23 |
| Rear parking brake recording little or no effort | 23 |
| Registration plate lamp issues | 11 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 11 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 8 |
| Horn not working |1.6.2a| | 8 |
| Registration plate issues | 8 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 7 |
| Service brake: efficiency below requirements |3.7.B.7| | 5 |
| Offside Rear fog lamp not working |1.3.2b| | 5 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 5 |
| Rear brake binding | 5 |
| Offside Headlamp not working on main beam |1.7.5a| | 4 |
| Windscreen washer not working | 4 |
| Nearside Side repeater not working |1.4.A.2c| | 4 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 3 |
| Offside front brake binding |3.7.B.1| | 3 |
| Brakes imbalanced across an axle | 3 |
| Brake hose damaged | 3 |
| Rear fog lamp not working |1.3.2b| | 3 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 3 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Rear fog lamp tell tale missing |1.3.1b| | 2 |
| Nearside front brake binding |3.7.B.1| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Front Brake hose bulging under pressure |3.6.B.3| | 2 |
| Horn not working |7.7 |a| |ii|| | 2 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Nearside Rear Service brake excessively binding |1.2.1 |f|| | 2 |
| Brake performance not tested |3.7.A.1| | 2 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Brake pipe excessively corroded | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front front brake binding |3.7.B.1| | 2 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Brake hose excessively deteriorated | 1 |
| Offside Rear Brake hose leaking |3.6.A.1| | 1 |
| Offside Front suspension has a suspension lower ball joint securing nut not locked |2.5.B.1a| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Hazard warning lamps inoperative |1.4.B.1b| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i)) | 1 |
| Parking brake lever releases when knocked |3.1.6a| | 1 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Offside Front Brake hose leaking |3.6.A.1| | 1 |
| Front brake application uneven | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| Nearside Rear Anti-roll bar cracked |2.4.G.1| | 1 |
| Offside Front Direction indicator adversely affected by the operation of another lamp Indicator was operating the side light and vice-versa. (4.4.3 (b)) | 1 |
| Nearside Windscreen wiper missing |3.4 |a|| | 1 |
| Offside Windscreen wiper missing plus wiper arms |3.4 |a|| | 1 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Nearside Front Road wheel more than one fixing missing |5.2.1 |a| |ii|| | 1 |
| Offside Front Road wheel more than one fixing missing |5.2.1 |a| |ii|| | 1 |
| Nearside Outer Integral body structure is deformed and structural rigidity is significantly reduced sill |6.1.1 |a| |i|| | 1 |
| Offside Outer Integral body structure is deformed and structural rigidity is significantly reduced sill |6.1.1 |a| |i|| | 1 |
| Nearside Steering rack has excessive free play detected at the steering wheel |steering rack fitted| |2.3 |a| |i|| | 1 |
| Offside Front Anti-roll bar linkage ball joint likely to become detached bush and nut missing |5.3.4 |a| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Outer Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Front Steering system lock to lock check exposes a seriously damaged brake hose |2.2.D.2b| | 1 |
| Offside Front Steering system lock to lock check exposes a seriously damaged brake hose |2.2.D.2b| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Nearside Rear Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt large clip (6.1.7 (g) (ii)) | 1 |
| Offside Rear Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt large clip (6.1.7 (g) (ii)) | 1 |
| Offside Rear Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt small clip (6.1.7 (g) (ii)) | 1 |
| Offside Windscreen wiper not operating over a large enough area to give an adequate view |8.2.1c| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Brake cable has restricted free movement |3.5.1k| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Brake hydraulic reservoir cap missing |3.6.G.1a| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Driver`s seat fore and aft adjustment mechanism not functioning as intended. |6.2.5 |b| |i|| | 1 |
| Exhaust emissions hydrocarbon content excessive |8.2.1.2 |b|| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Headlamp aim not tested |1.8.A.1c| | 1 |
| Offside Lower Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Fuel system component insecure |7.2.1| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Nearside Rear Hydraulic brake cylinder leaking hydraulic fluid (1.1.16 (b) (i)) | 1 |
| Front Service brake excessively binding both sides (1.2.1 (f)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Rear Braking system leaking |3.6.A.1| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Nearside Front brake disc has restricted free movement |3.5.1j| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Nearside Rear Rear fog lamp flickers when tapped lightly by hand |1.1.6d| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Centre Rear fog lamp not working |1.3.2b| | 1 |
| Rear Fuel pipe leaking |7.2.3| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Centre Front Obligatory mirror missing |8.1.1| | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Rear Brake hose bulging under pressure |3.6.B.3| | 1 |
| Horn sound not in accordance with requirements (7.7 (c)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Front Outer Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced sill marked with yellow chalk |6.1.1 |c| |i|| | 1 |
| Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Brake performance not tested severe binding on brakes |1.2.1 |g|| | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside front parking brake recording little or no effort |3.7.B.6a| | 1 |
| Offside front parking brake recording little or no effort |3.7.B.6a| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Passenger`s seat insecure |6.2.A.1| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Offside Rear Braking system leaking |3.6.A.1| | 1 |
| Nearside Rear Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Rear Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Headlamp switch faulty |1.7.1| | 1 |
| Nearside Front An item not tested |Manual| | 1 |
| Offside Front An item not tested |Manual| | 1 |
| Parking brake lever ratchet mechanism worn to the extent that the brake may inadvertently release (1.1.6 (b) (ii)) | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Brake hose has insufficient room to move | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement Both n/s and o/s D bushes. |2.4.G.2| | 1 |
| Nearside All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Offside All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Front coil spring broken |2.4.C.1a| | 1 |