| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 19 |
| Registration plate issues | 12 |
| Parking brake: efficiency below requirements |3.7.B.7| | 10 |
| Rear parking brake recording little or no effort | 9 |
| Rear fog lamp not working |1.3.2b| | 7 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 7 |
| Brake hose excessively deteriorated | 7 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 6 |
| Offside Rear fog lamp not working |1.3.2b| | 6 |
| Registration plate lamp issues | 6 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 6 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 6 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 4 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 3 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 3 |
| Offside Side repeater not working |1.4.A.2c| | 3 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 3 |
| Front position lamp|s| not working |1.1.A.3b| | 3 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 2 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 2 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Rear brake binding | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Rear fog lamp tell tale missing |1.3.1b| | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 2 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Offside Rear fog lamp missing (4.5.1 (a) (ii)) | 2 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Front brake disc in such a condition that it is seriously weakened | 2 |
| Brake pipe excessively corroded | 2 |
| Windscreen has damage | 2 |
| Drivers door catch insecure adjusted (6.2.3 (c) (ii)) | 1 |
| Nearside Front Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Offside Front Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Rear Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Rear fog lamp switch missing (4.5.3 (a) (ii)) | 1 |
| Nearside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Brake hose stretched |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Offside Front Suspension weakened allowing body or other component to foul a road wheel or would do so if laden |2.4.A.1b| | 1 |
| Offside Front Front suspension has a suspension upper ball joint securing nut loose |2.5.B.1a| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Offside Side repeater has less than 50% of the light sources illuminating |1.4.A.2c| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Front Headlamp not working on dipped beam also Headlamp light source not compatible aftermarket LEDS fitted (4.1.1 (a) (ii)) | 1 |
| Nearside Front Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Road wheel fixing loose (5.2.1 (a) (i)) | 1 |
| Nearside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Rear fog lamp excessively deteriorated so that it is not visible from a reasonable distance |1.3.2d| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Seat belt installation anchorage insecure bolt missing centre rear |5.3.1d| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Position lamp with a multiple light source more than 1/2 not functioning (4.2.1 (a) (ii)) | 1 |
| Offside Rear Position lamp with a multiple light source more than 1/2 not functioning (4.2.1 (a) (ii)) | 1 |
| Nearside Rear Stop lamp(s) with a multiple light source more than 1/2 not functioning (4.3.1 (a) (ii)) | 1 |
| Offside Rear Stop lamp(s) with a multiple light source more than 1/2 not functioning (4.3.1 (a) (ii)) | 1 |
| Central Exhaust has a major leak of exhaust gases Exhaust box (6.1.2 (a)) | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Leaf spring to axle securing bolt insecure front at spring eye |2.4.B.7b| | 1 |
| Nearside Rear Leaf spring to axle securing bolt insecure u-bolts slack round axle |2.4.B.7b| | 1 |
| Nearside Rear Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Offside Rear Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Offside Rear Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Nearside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Stop lamp|s| all not working |4.3.1 |a| |iii|| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Electrical wiring insulation so damaged or deteriorated it is likely to cause a short-circuit |4.11 |c| |ii|| | 1 |
| Electrical wiring heavily deteriorated |4.11 |b| |ii|| | 1 |
| Fuel hose insecure lpg |6.1.3 |a| |i|| | 1 |
| Nearside Exhaust system insecure |6.1.2 |a|| | 1 |
| Offside Exhaust system insecure |6.1.2 |a|| | 1 |
| Nearside Front Anti-roll bar attachment bracket/mounting insecure |5.3.3 |a| |i|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength shock absorber |5.3.6 |a| |i|| | 1 |
| Power steering component|s| leaking Oil cooler |2.3.3b| | 1 |
| Power steering component|s| leaking Rack |2.3.3b| | 1 |
| Front Anti-roll bar linkage has excessive play in a ball joint Both sides |2.4.G.2| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Front Position lamp not working both (4.2.1 (a) (ii)) | 1 |
| Offside Front position lamp|s| insecure |1.1.A.3a| | 1 |
| Nearside Front position lamp|s| insecure |1.1.A.3a| | 1 |
| Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Lower Shock absorber insecure mounting bolt loose |2.7.2b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Anti-roll bar linkage has excessive play in a ball joint both front |2.4.G.2| | 1 |
| Front suspension has excessive play in a lower suspension ball joint both front |2.5.B.1a| | 1 |
| Electrical wiring insulation in such a condition there is an imminent risk of fire or formation of sparks At nearside rear sitting on exhaust pipe |4.11 |c| |iii|| | 1 |
| Centre Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Nearside Side repeater does not face the side |1.4.A.2b| | 1 |
| Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Offside Front Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Rear Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Brake hose has insufficient room to move | 1 |
| Brakes imbalanced across an axle | 1 |
| Front Headlamp aim projected beam image is obviously incorrect both sides (4.1.2 (c)) | 1 |
| Nearside Front position lamp(s) incorrect colour (1.1.A.3e) | 1 |
| Offside Front position lamp(s) incorrect colour (1.1.A.3e) | 1 |
| Nearside Rear Direction indicator incorrect colour (1.4.A.2f) | 1 |
| Offside Rear Direction indicator incorrect colour (1.4.A.2f) | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Rear Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Rear Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Nearside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Headlamp insecure (4.1.1 (c)) | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Obligatory mirror insecure (3.3 (b) (ii)) | 1 |
| Offside Rear fog lamp obviously incorrectly positioned (4.5.4 (a)) | 1 |
| Nearside Rear Position lamp showing white light to the rear (4.2.3 (a) (ii)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Rear Seat belt not functioning as intended both (7.1.2 (c)) | 1 |
| Front Headlamp aim projected beam image is obviously incorrect both (4.1.2 (c)) | 1 |
| Front Headlamp lens seriously defective both (4.1.1 (b) (ii)) | 1 |
| Front Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Front Brake disc significantly and obviously worn both (1.1.14 (a) (i)) | 1 |
| Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Hazard warning lamps inoperative (4.4.1 (e)) | 1 |
| Rear fog lamp tell-tale missing (4.9.1 (a) (ii)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Upper Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Upper Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Side repeater insecure |1.4.A.2b| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Battery insecure |1.9.1| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Brake performance not tested due to being unable to rotate offside rear wheel (1.2.1 (g)) | 1 |
| Nearside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Offside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Nearside Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Offside Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b)) | 1 |
| Nearside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Offside Side repeater missing (4.4.1 (a) (ii)) | 1 |
| Rear fog lamp switch missing (4.5.3 (a)) | 1 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Offside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Rear Rear fog lamp missing |1.3.2a| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Emissions not tested |7.0| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Upper Power steering pipe/hose leaking (2.1.5 (a)) | 1 |
| Offside Front Power steering component leaking steering rack. (2.1.5 (a)) | 1 |
| Windscreen wiper not working both fronts. (3.4 (a)) | 1 |
| Offside Front Power steering component leaking steering rack |2.1.5 |a|| | 1 |
| Nearside Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Inner sill excessively corroded near to body mounts (6.2.2 (d) (i)) | 1 |
| Offside Rear Parking (secondary brake) on a single line braking system has no recorded effort at a wheel (1.3.1 (a) (ii)) | 1 |
| Offside Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting Inner sill excessively corroded near to body mount (6.2.2 (d) (i)) | 1 |
| Nearside Rear Parking (secondary brake) on a single line braking system has no recorded effort at a wheel (1.3.1 (a) (ii)) | 1 |
| Central Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Headlamp are incorrectly positioned (4.1.4 (a)) | 1 |
| Offside Headlamp are incorrectly positioned (4.1.4 (a)) | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Power steering component leaking rack (2.1.5 (a)) | 1 |
| Nearside Front Wheel bearing has excessive play bolts loose (5.1.3 (a) (i)) | 1 |
| Rear Brake pipe leaking |3.6.A.1| | 1 |
| Front position lamp|s| incorrect colour both |1.1.A.3e| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Nearside Front Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
| Front Brake performance not tested |3.7.A.1| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Lower Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Nearside Lower Seat belt anchorage prescribed area strength or continuity significantly reduced inner and outer sill (7.1.1 (a) (i)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Rear Body component corroded and likely to cause injury bumper (6.2.1 (a) (i)) | 1 |
| Rear Direction indicator incorrect colour n/s & o/s |1.4.A.2f| | 1 |
| Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Brake lever has restricted free movement |3.5.1k| | 1 |