| Most common failures | No# failures |
|---|
| Registration plate issues | 13 |
| Registration plate lamp issues | 13 |
| Headlamp aim out of alignment | 10 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 9 |
| Offside Rear fog lamp not working |1.3.2b| | 9 |
| Parking brake: efficiency below requirements |3.7.B.7| | 8 |
| Service brake: efficiency below requirements |3.7.B.7| | 7 |
| Brakes imbalanced across an axle | 7 |
| Brake pipe excessively corroded | 6 |
| Rear fog lamp not working |1.3.2b| | 5 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 5 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 4 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 4 |
| Rear fog lamp missing |1.3.2a| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Battery insecure |1.9.1| | 3 |
| Offside front brake binding |3.7.B.1| | 3 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Power steering pump leaking from a failed component |2.3.3b| | 2 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 2 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Service brake: efficiency below requirements |3.7.C.1a| | 2 |
| Direction indicators not working |1.4.A.2c| | 2 |
| Hazard warning lamps inoperative |1.4.B.1b| | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 2 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Offside Rear fog lamp missing |1.3.2a| | 2 |
| Horn not working |1.6.2a| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Statutory seat belt missing |5.1.1| | 1 |
| Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Offside Front Fuel hose leaking |7.2.3| | 1 |
| Offside Front Lower Direction indicator not working |1.4.A.2c| | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Nearside Rear Seat belt cut sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Brake pipe excessively damaged front to rear (1.1.11 (c)) | 1 |
| Exhaust fumes entering cabin rear section of exhaust missing (6.1.2 (b) (i)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Emissions not tested exhaust pipe missing at rear (8.2.1.2 (d)) | 1 |
| Offside Front Passenger`s seat insecure |6.2.A.1| | 1 |
| Electrical wiring insecure around throttle pedal |1.9.2a| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases section missing |6.1.2 |a|| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Drivers seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i)) | 1 |
| Passengers seat backrest cannot be secured in the upright position. (6.2.6 (a) (i)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Outline marker lamp not working (4.2.1 (a) (ii)) | 1 |
| Headlamp aim projected beam image is obviously incorrect Both lights (4.1.2 (c)) | 1 |
| Electrical wiring insecure and connectors likely to become disconnected Rear interior wiring for entertainment, lights ans rear cluster lights (4.11 (a) (ii)) | 1 |
| Direction indicator not working All indicators near side do not flash (4.4.1 (a) (ii)) | 1 |
| Main beam tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Headlamp excessively deteriorated so that the light output is severely reduced both front |1.7.5a| | 1 |
| Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover insecure so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Front Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Offside Rear Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Side repeater has less than 50% of the light sources illuminating |1.4.A.2c| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Centre Front Passenger`s seat cannot be secured in the upright position. missing |6.2.A.2| | 1 |
| Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Hazard warning switch inoperative |4.4.2 |a| |ii|| | 1 |
| Front Lower Suspension arm ball joint excessively worn both sides |5.3.4 |a| |i|| | 1 |
| Trailer electrical socket likely to become detached |4.10 |a| |ii|| | 1 |
| Exhaust emissions - engine idle speed too high |8.2.1.2 |e|| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Parking brake lever ratchet mechanism is broken |3.1.5| | 1 |
| Ball joint has excessive play |2.2.B.1f| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover missing |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover missing |2.4.G.2| | 1 |
| Nearside Headlamp not working on main beam |4.1.1 |a| |ii|| | 1 |
| Nearside Front Upper Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
| Parking brake lever ratchet not holding correctly (1.1.6 (a)) | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Power steering pump leaking from a failed joint |2.3.3b| | 1 |
| Nearside Inner Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Rear Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Front passenger seat insecure |6.2.3| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Fuel pipe leaking |7.2.3| | 1 |
| Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Offside Front Headlamp insecure |1.7.3| | 1 |
| Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
| Rear fog lamp missing (4.5.1 (a) (ii)) | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Parking brake lever ratchet mechanism is excessively worn |3.1.5| | 1 |
| Brake pipe leaking on a hydraulic braking system Front to rear by fuel tank and chassis area |1.1.11 |b| |ii|| | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Front Upper Axle swivel joint has excessive play in a ball joint |2.5.A.3b| | 1 |
| Nearside Front drive shaft coupling is excessively worn |2.5.C.1c| | 1 |
| Nearside Front Driver`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Windscreen has damage | 1 |
| Centre Upper Stop lamp not working |1.2.1b| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Front constant velocity joint is excessively worn |2.5.C.1b| | 1 |
| Steering wheel in a condition that hampers proper control |2.1.1| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Offside Windscreen wiper blade missing |8.2.2| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Side repeater missing |4.4.1 |a| |ii|| | 1 |
| Offside Side repeater missing |4.4.1 |a| |ii|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 1 |
| Nearside Front Panhard rod worn and seriously weakened |2.4.G.1| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Horn emits two or more alternating tones |1.6.2d| | 1 |
| Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak |8.2.1.1 |b|| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Offside Front Valve stem seriously damaged |4.1.D.1e| | 1 |