| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 13 |
| Registration plate issues | 13 |
| Headlamp aim out of alignment | 10 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Rear fog lamp not working |1.3.2b| | 7 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 6 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 6 |
| Offside Rear fog lamp not working |1.3.2b| | 5 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 4 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 4 |
| Nearside Side repeater missing |1.4.A.2b| | 4 |
| Offside Side repeater missing |1.4.A.2b| | 4 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 4 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 3 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Brake pipe excessively corroded | 3 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Rear parking brake recording little or no effort | 2 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturers specified limits (8.2.1.2 (a)) | 2 |
| Brakes imbalanced across an axle | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 2 |
| Rear fog lamp switch missing |1.3.1a| | 2 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Offside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 2 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Emissions not tested (8.2.1.2 (d)) | 2 |
| Offside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Power steering component|s| leaking |2.3.3b| | 2 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 2 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Battery insecure and likely to fall from carrier (4.13 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Offside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Front Obligatory mirror seriously damaged, affecting the rear view |3.3 |b| |ii|| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |3.3 |b| |ii|| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Power steering component leaking around rack area |2.1.5 |a|| | 1 |
| Track rod end ball joint has excessive play BOTH (2.1.3 (b) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt SPLIT (6.1.7 (g) (ii)) | 1 |
| Nearside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Side repeater not working BOTH (4.4.1 (a) (ii)) | 1 |
| Nearside Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Front Headlamp has a product on the light source so that the light output is severely reduced Both (4.1.4 (b)) | 1 |
| Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust carbon monoxide content at idle exceeds manufacturers specified limits (8.2.1.2 (b)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Fuel cap/sealing device ineffective (6.1.3 (b) (i)) | 1 |
| Rear Rear fog lamp missing |1.3.2a| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Rear brake binding | 1 |
| Brake performance unable to be tested o/s/f pad is metal to metal (1.2.1 (g)) | 1 |
| Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Exhaust system insecure brick wedged in chassis (6.1.2 (a)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Exhaust silencer likely to become detached (8.1.1 (b) (ii)) | 1 |
| Offside Front Headlamp insecure (4.1.1 (c)) | 1 |
| Emission control equipment missing where fitted as standard (8.2.1.1 (a)) | 1 |
| Emissions oxygen sensor missing where one was fitted as standard (8.2.1.1 (a)) | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition (8.1.1 (a)) | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting centre body mounting structure damaged (6.2.2 (d) (i)) | 1 |
| Nearside Upper Stop lamp not working |1.2.1b| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear Shock absorbers damaged to the extent that it does not function (5.3.2 (b)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Anti-roll bar linkage insecurely attached (5.3.3 (a) (i)) | 1 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Power steering component|s| leaking from a failed seal |2.3.3b| | 1 |
| Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Front Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Nearside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Front Shock absorbers has a serious fluid leak | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Central Rear Seat belt buckle missing (7.1.2 (d)) | 1 |
| Central Rear Seat belt anchorage loose (7.1.1 (b)) | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Anti-roll bar linkage ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Offside Front Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm locating pin insecure |2.4.G.3a| | 1 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced Inner side of body at sill corroded away, within prescribed area criteria. (7.1.1 (a) (i)) | 1 |
| Exhaust system insecure Damaged bracket (6.1.2 (a)) | 1 |
| Front Anti-roll bar linkage ball joint excessively worn Both sides (5.3.4 (a) (i)) | 1 |
| Nearside Front Leaf spring fractured |2.4.B.1a| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Stop lamp not working both |1.2.1b| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Emissions unable to be completed (8.2.1.2 (d)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Front Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Rear Shock absorbers has a serious fluid leak | 1 |