| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 33 |
| Headlamp aim out of alignment | 26 |
| Registration plate issues | 14 |
| Windscreen wiper does not clear the windscreen effectively | 12 |
| Offside Rear fog lamp not working |1.3.2b| | 11 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 9 |
| Rear fog lamp not working |1.3.2b| | 8 |
| Rear fog lamp tell tale not working |1.3.1b| | 7 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 7 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 6 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Rear parking brake recording little or no effort | 5 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 5 |
| Anti-lock braking system warning lamp indicates an ABS fault | 5 |
| Nearside Side repeater missing |1.4.A.2b| | 4 |
| Offside Side repeater missing |1.4.A.2b| | 4 |
| Offside Side repeater not working |1.4.A.2c| | 3 |
| Windscreen has damage | 3 |
| Rear fog lamp switch missing |1.3.1a| | 3 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 3 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
| Brake hose excessively deteriorated | 3 |
| Emissions not tested |7.0| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Front brake excessively fluctuating | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Offside front brake binding |3.7.B.1| | 2 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 2 |
| Horn not working |1.6.2a| | 2 |
| Brakes imbalanced across an axle | 2 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 2 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 2 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Exhaust has a part missing |7.1.1a| | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Power steering pipe(s) or hose(s) leaking from a joint (2.3.3b) | 2 |
| Nearside Front Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Rear brake binding | 2 |
| Front brake application uneven | 2 |
| Nearside Outer Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Outer Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Brake hose excessively damaged |3.6.B.4d| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Towbar component defective (6.1.6 (a)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Rear Brake hose exposed to excessive heat |3.6.B.4f| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Offside Obligatory mirror does not provide a view to the rear |3.3 |c|| | 1 |
| Nearside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer`s specified limits |8.2.1.2 |a|| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits |8.2.1.2 |b|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Exhaust has a part missing |7.1.1a| | 1 |
| Anti-lock braking system warning lamp is missing. |3.4.1a| | 1 |
| Offside Obligatory mirror seriously deteriorated, affecting the rear view |8.1.2a| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint too rack |2.3.3b| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Nearside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Power steering pipe|s| or hose|s| leaking from a joint |2.3.3b| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Brake pipe excessively corroded | 1 |
| Nearside Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Centre Front Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside Rear Lower Exhaust has a part missing |7.1.1a| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Front Upper Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Upper Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Nearside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Offside Front Side repeater not working |4.4.1 |a| |ii|| | 1 |
| Nearside Rear brake disc excessively scored |3.5.1h| | 1 |
| Offside Rear brake disc excessively scored |3.5.1h| | 1 |
| Nearside Front brake disc has restricted free movement |3.5.1j| | 1 |
| Offside Front brake disc has restricted free movement |3.5.1j| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Rear rear brakes release unevenly |3.7.B.4| | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Centre Front Upper Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Offside Front Hydraulic brake cylinder leaking hydraulic fluid |1.1.16 |b| |i|| | 1 |
| Nearside Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt lower ball joint |2.4.G.2| | 1 |
| Offside Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt lower ball joint |2.4.G.2| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Front Power steering component(s) leaking (2.3.3b) | 1 |
| Nearside Headlamp aim beam image obviously incorrect (1.8.A.1b) | 1 |
| Supplementary Restraint System warning lamp indicates a fault (5.4.2) | 1 |
| Nearside Front wheel bearing has excessive play (2.5.A.3c) | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint (2.4.G.2) | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint (2.4.G.2) | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone A (8.3.1e) | 1 |
| Offside Front Lower Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Lower Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Position lamp not working All (4.2.1 (a) (ii)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt SPLIT (5.3.4 (b) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt BOOT SPLIT (5.3.4 (b) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt BOOT SPLIT (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt BOOT SPLIT (5.3.4 (b) (ii)) | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Windscreen washer not working | 1 |
| Nearside Rear Service brake is causing the vehicle to swerve to the nearside (1.2.1 (b) (i)) | 1 |
| Nearside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Front Upper Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Offside Front Headlamp incorrect colour |1.7.5b| | 1 |
| Nearside Front Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Exhaust system insecure (6.1.2 (a)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Central Front Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Offside Front brake disc excessively scored |3.5.1h| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Rear fog lamp switch missing (4.5.3 (a) (ii)) | 1 |
| Central Rear Seat belt missing (7.1.2 (a)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Nearside Rear Road wheel cracked |4.2.A.1a| | 1 |
| Exhaust emissions hydrocarbon content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Nearside Rear Electrical wiring damaged and bare wires exposed On Tow bar bracket |1.9.2c| | 1 |
| Nearside Rear Electrical wiring damaged and bare wires exposed Next to spare wheel |1.9.2c| | 1 |
| Nearside Front Side repeater missing |1.4.A.2b| | 1 |
| Offside Front Side repeater missing |1.4.A.2b| | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Drag link end ball joint has excessive play Drop arm ball joint from steering box |2.2.B.1f| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Central Exhaust has a major leak of exhaust gases Silencer split pipe/loose |7.1.2| | 1 |
| Emissions not tested Major leak of exhaust system |7.3.A.1| | 1 |
| Rear fog lamp switch faulty |1.3.1a| | 1 |
| Nearside Front position lamp|s| insecure |1.1.A.3a| | 1 |
| Offside Front position lamp|s| insecure |1.1.A.3a| | 1 |
| Nearside Front position lamp|s| flickers when tapped lightly by hand |1.1.4c| | 1 |
| Offside Front position lamp|s| flickers when tapped lightly by hand |1.1.4c| | 1 |
| Exhaust noise is clearly in excess of that emitted by a similar vehicle fitted with a standard silencer in average condition |7.1.4| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Offside Front Drive shaft uj which forms part of the suspension has excessive play in a universal joint |2.4.G.4b| | 1 |
| Rear Stop lamp not working |1.2.1b| | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 1 |
| Offside Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Direction indicator incorrect colour (4.4.3 (a)) | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Suspension arm has excessive play in a ball joint bottom ball joint |2.4.G.2| | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |