| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 10 |
| Windscreen wiper does not clear the windscreen effectively | 8 |
| Headlamp aim out of alignment | 7 |
| Parking brake: efficiency below requirements |3.7.B.7| | 6 |
| Rear parking brake recording little or no effort | 4 |
| Brakes imbalanced across an axle | 3 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 3 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 3 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Registration plate issues | 2 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 2 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |seat mount prescribed area| |6.1.B.2| | 1 |
| Offside Rear Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill |seat mount prescribed area| |6.1.B.2| | 1 |
| Inner Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Front Panhard rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Steering locking device missing trackrod end |2.2.C.1g| | 1 |
| Inner Steering locking device missing trackrod end |2.2.C.1g| | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Panhard rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Front Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt top |2.2.C.1c| | 1 |
| Offside Front Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt top |2.2.C.1c| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering chassis |6.1.A.1| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering chassis |6.1.A.1| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Rear fog lamp insecure |1.3.2a| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Drag link end ball pin shank loose |2.2.B.1c| | 1 |
| Parking brake lever defective so that it cannot be satisfactorily operated |3.1.3c| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Nearside Front Side repeater insecure |1.4.A.2b| | 1 |
| Offside Front Side repeater insecure |1.4.A.2b| | 1 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Centre Front Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Side repeater incorrect colour (4.4.3 (a)) | 1 |
| Offside Passenger`s seat cannot be secured in the upright position. |6.2.A.2| | 1 |
| Brake hose damaged | 1 |
| Brake hose has insufficient room to move | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Offside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |