| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 30 |
| Headlamp aim out of alignment | 28 |
| Windscreen wiper does not clear the windscreen effectively | 14 |
| Centre Stop lamp not working |1.2.1b| | 13 |
| Brake hose excessively deteriorated | 13 |
| Anti-lock braking system warning lamp indicates an ABS fault | 10 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 9 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 9 |
| Registration plate issues | 8 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 7 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 7 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 6 |
| Offside Front Position lamp not working |4.2.1 |a|| | 6 |
| Rear brake disc in such a condition that it is seriously weakened | 6 |
| Windscreen washer not working | 6 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 5 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 5 |
| Front brake disc in such a condition that it is seriously weakened | 4 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Brakes imbalanced across an axle | 4 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 4 |
| Rear fog lamp not working |1.3.2b| | 4 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 4 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Brake pedal has insufficient reserve travel (1.1.2 (a)) | 3 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 3 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 2 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Nearside Rear Sub-frame pin or bush likely to become detached (5.3.4 (a) (ii)) | 2 |
| Offside Rear Sub-frame pin or bush likely to become detached (5.3.4 (a) (ii)) | 2 |
| Centre Rear Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 2 |
| Offside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 2 |
| Nearside Front Headlamp insecure (4.1.1 (c)) | 2 |
| Driver`s airbag obviously defective |5.4.1| | 2 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 2 |
| Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 2 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Upper Stop lamp not working |1.2.1b| | 2 |
| Centre Upper Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 2 |
| Brake fluid contaminated (1.8 (a)) | 2 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 2 |
| Rear fog lamp missing |1.3.2a| | 1 |
| Rear fog lamp tell tale missing |1.3.1b| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Brake pedal creeps down when held under pressure |3.3.B.1a| | 1 |
| Nearside Rear Sub-frame pin or bush likely to become detached Mounting bush has no metal surrounding it (5.3.4 (a) (ii)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Offside Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Offside Rear Parking |secondary brake| on a single line braking system grabbing severely |1.3.1 |c|| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Rear Exhaust has a major leak of exhaust gases silencer |7.1.2| | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b)) | 1 |
| Emissions not tested (8.2.1.2 (d)) | 1 |
| Supplementary restraint system warning lamp indicates a fault code read vehicle came up with squib fault (7.1.6 (a)) | 1 |
| Central Stop lamp(s) not working Rectified (4.3.1 (a) (ii)) | 1 |
| Nearside Front Position lamp not working Rectified (4.2.1 (a) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Offside Front Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Offside Rear Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Nearside Front Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Nearside Rear Road wheel fixing missing |5.2.1 |a| |i|| | 1 |
| Power steering pump drive system defective |2.3.6| | 1 |
| Outer Rear Upper Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Valve stem seriously damaged |4.1.D.1e| | 1 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Front Outer Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Windscreen wiper not working |3.4 |a|| | 1 |
| Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Front Windscreen wiper not working |3.4 |a|| | 1 |
| All direction indicators not working all |4.4.1 |a| |ii|| | 1 |
| Side repeater not working both |4.4.1 |a| |ii|| | 1 |
| Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
| Bootlid cannot be secured in the closed position |6.4.1| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Drivers view of the road through the swept area of the windscreen materially affected by an obstruction items hanging from interior rear-view mirror (3.1 (a) (ii)) | 1 |
| Central Upper Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Suspension arm ball joint likely to become detached (5.3.4 (a) (ii)) | 1 |
| Central Front Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Offside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i)) | 1 |
| Nearside Rear Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Offside Rear Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Central Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Service brake grabbing severely |1.2.1 |c|| | 1 |
| Offside Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Nearside Front Track rod end ball joint worn to the extent there is a serious risk of detachment |2.1.3 |b| |ii|| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Subframe mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Central Rear Seat belt retracting mechanism defective also routing of belt |5.2.5b| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front Position lamp with a multiple light source more than 1/2 not functioning (4.2.1 (a) (ii)) | 1 |
| Offside Front Position lamp with a multiple light source more than 1/2 not functioning (4.2.1 (a) (ii)) | 1 |
| Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Headlamp aim not tested lamp not working (4.1.2 (b)) | 1 |
| Front Body insecure and dangerous to other road users |6.1.B.1b| | 1 |
| Nearside Rear Body has a sharp edge caused by damage position lamp lens broken emitting a light other than red |6.1.C.1| | 1 |
| Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt |5.2.2a| | 1 |
| Rear Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Oil leaking excessively from engine Sump (8.4.1 (a) (i)) | 1 |
| Brake lever has insufficient reserve travel Handbrake (1.1.2 (a)) | 1 |
| Front position lamp|s| not working Both front. |1.1.A.3b| | 1 |
| Nearside Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Nearside Rear Outer Brake disc fractured outer face missing large segment of friction surface (1.1.14 (a) (ii)) | 1 |
| Nearside Rear Sub-frame pin or bush excessively worn rear subframe bushes on the ns are corroded away in subframe (5.3.4 (a) (i)) | 1 |
| Offside Rear Sub-frame pin or bush excessively worn rear subframe both bushes corroded away in subframe (5.3.4 (a) (i)) | 1 |
| Offside Front Outer Track rod end ball joint has excessive play outer track rod end (2.1.3 (b) (i)) | 1 |
| Offside Front Inner Track rod end ball joint has excessive play inner tie rod end to rack excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Road wheel badly distorted (5.2.2 (c) (i)) | 1 |
| Exhaust tailpipe not capable of allowing the emission probe to be inserted |7.3.D.1| | 1 |
| Central Stop lamp not working |1.2.1b| | 1 |
| Brake hydraulic reservoir cap missing |3.6.G.1a| | 1 |
| Offside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear Sub-frame corroded and seriously weakened Around bolt mounting (5.3.3 (b) (i)) | 1 |
| Offside Rear Sub-frame corroded and seriously weakened Around bolt mounting (5.3.3 (b) (i)) | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm ball joint excessively worn ball joint (5.3.4 (a) (i)) | 1 |
| Front Track rod end ball joint has excessive play BOTH (2.1.3 (b) (i)) | 1 |
| Offside Front Obligatory mirror insecure (3.3 (b) (ii)) | 1 |
| Front Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Brake performance unable to be tested (1.2.1 (g)) | 1 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Lower Steering linkage ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Rear Brake disc significantly and obviously worn both sides (1.1.14 (a) (i)) | 1 |
| Rear Service brake excessively fluctuating both sides (1.2.1 (e)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn arm rear mounting bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Lower Suspension arm pin or bush excessively worn rear mounting bush (5.3.4 (a) (i)) | 1 |
| Driver`s airbag obviously defective light present on dash |5.4.1| | 1 |
| Exhaust emissions exceed default limit of 1.5m-1 (8.2.2.2 (b)) | 1 |
| Nearside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Service brake excessively binding |1.2.1 |f|| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front brake caliper leaking |3.6.A.1| | 1 |
| Nearside Rear Service brake excessively binding Unable to check hub bearing etc due to binding brake. (1.2.1 (f)) | 1 |
| Front passenger door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Centre Rear Stop lamp has less than 50% of the light sources illuminating |1.2.1b| | 1 |
| Front Outer Suspension arm ball joint excessively worn nearside and offside (5.3.4 (a) (i)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Front front brake binding |3.7.B.1| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Fuel cap/sealing device missing |6.1.3 |b| |i|| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Sub-frame corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Rear Suspension arm pin or bush excessively worn trailing arm bush (5.3.4 (a) (i)) | 1 |
| Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Outer Upper Stop lamp not working |1.2.1b| | 1 |
| Stop lamp not working high level |1.2.1b| | 1 |
| Nearside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
| Nearside Front Lower Suspension arm pin or bush excessively worn rear bush |5.3.4 |a| |i|| | 1 |
| Offside Rear Brake linkage has restricted free movement |1.1.15 |e|| | 1 |
| Nearside Rear Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sub/frame mtg |6.2.2 |d| |i|| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm pin or bush excessively worn rear (5.3.4 (a) (i)) | 1 |
| Nearside Rear Sub-frame pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Sub-frame pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Macpherson strut likely to fail Strut hydraulic plunger insecure has excessive movement (5.3.3 (b) (ii)) | 1 |
| Nearside Rear Valve stem seriously damaged (5.2.3 (j)) | 1 |
| Offside Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Offside Rear Rear fog lamp lens defective such that emitted light is adversely affected |4.5.1 |b| |ii|| | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Brake lever has insufficient reserve travel |1.1.2 |a|| | 1 |
| Nearside Front Brake hose damaged and likely to fail (1.1.12 (a)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Track rod end ball joint worn to the extent there is a serious risk of detachment (2.1.3 (b) (ii)) | 1 |
| Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |