| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 14 |
| Parking brake: efficiency below requirements |3.7.B.7| | 11 |
| Brake hose excessively deteriorated | 6 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Registration plate lamp issues | 5 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 4 |
| Brakes imbalanced across an axle | 3 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 3 |
| Rear parking brake recording little or no effort | 3 |
| Offside Side repeater not working |1.4.A.2c| | 3 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 3 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 3 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Power steering fluid level below minimum |2.3.1| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Offside Front Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Horn not working |1.6.2a| | 2 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| All position lamps not working |1.1.A.3b| | 2 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Front Brake hose bulging under pressure |3.6.B.3| | 2 |
| Offside Rear Sub-frame has excessive play in a pin/bush |2.4.G.2| | 2 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Rear Coil spring fractured or broken |5.3.1 |b| |i|| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Brake lever has insufficient reserve travel |1.1.2 |a|| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Outer Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Centre Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Rear Brake lining|s| less than 1.5 mm thick |3.5.1g| | 1 |
| Offside Rear An item not tested |Manual| | 1 |
| Nearside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Offside Rear Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Main beam `tell-tale` not working |1.7.4c| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside brake caliper securing device missing |3.5.1j| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength N/S REAR CHASIS SECTION CORRODED AND HOLED (5.3.6 (a) (i)) | 1 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength N/S REAR INNER SILL & LOWER WHEEL ARCH AREA CORRODED AND HOLED (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength N/S FRONT CHASSIS PLATED AREA, CORRODED AND HOLED (5.3.6 (a) (i)) | 1 |
| Direction indicator not working |1.4.A.2c| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
| Offside Front Bonded suspension unit deteriorated and cannot function as intended |2.4.F.3| | 1 |
| Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Coil spring mounting corroded and seriously weakened |2.4.C.3c| | 1 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Sub-frame rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Sub-frame rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Rear An item not tested |Manual| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Steering wheel retaining device insecure |2.1.6| | 1 |
| Offside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
| Registration plate issues | 1 |
| Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front brake disc insecure |3.5.1i| | 1 |
| Nearside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Brake actuating linkage mounting prescribed area is excessively corroded |3.3.A.2| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Power steering ram|s| leaking from a failed component |2.3.3b| | 1 |
| Front brake application uneven | 1 |
| Centre Statutory seat belt missing |5.1.1| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Inner Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Outer Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Upper Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Centre Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Power steering component|s| leaking |2.3.3b| | 1 |
| Anti-lock braking system warning lamp indicates an ABS fault | 1 |
| Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Offside Front Upper Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Front Brake pipe leaking |3.6.A.1| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Offside Front Headlamp not in good working order |not working| |1.2.4a| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Front Brake hose bulging under pressure |3.6.B.3| | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Rear Service brake excessively fluctuating (1.2.1 (e)) | 1 |
| Offside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 1 |
| Offside Front Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Sub-frame attachment bracket/mounting worn and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Rear Sub-frame attachment bracket/mounting damaged and its strength is seriously reduced |2.4.G.1| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Rear passenger door catch deteriorated so the door cannot be readily opened or closed |6.2.B.2| | 1 |
| Windscreen wiper does not clear the windscreen effectively | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Front Sub-frame attachment rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) | 1 |
| Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Exhaust carbon monoxide content at idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |