| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 29 |
| Windscreen wiper does not clear the windscreen effectively | 15 |
| Rear parking brake recording little or no effort | 13 |
| Headlamp aim out of alignment | 9 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 6 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 6 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 5 |
| Rear brake binding | 5 |
| Brake pipe excessively corroded | 5 |
| Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 5 |
| Anti-lock braking system warning lamp indicates an ABS fault | 4 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 4 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 4 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 4 |
| Brakes imbalanced across an axle | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 3 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Registration plate lamp issues | 3 |
| Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Nearside Side repeater not working |1.4.A.2c| | 2 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 2 |
| Power steering component|s| leaking |2.3.3b| | 2 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Registration plate issues | 2 |
| Brake hose excessively deteriorated | 2 |
| Position lamp switch faulty |1.1.A.1| | 2 |
| Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Front brake application uneven | 2 |
| Offside Rear fog lamp not working |1.3.2b| | 2 |
| Emissions not tested |7.0| | 2 |
| Nearside Rear Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Power steering malfunctioning |2.3.3a| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Horn not working |1.6.2a| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Offside Rear Lower Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Offside Front suspension has excessive play in a pin or bush of an upper wishbone inner bearing |2.5.B.1a| | 1 |
| Nearside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement linkpin |2.4.G.2| | 1 |
| Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement both front / rear |2.4.G.2| | 1 |
| Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement both front / rear |2.4.G.2| | 1 |
| Offside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Anti-roll bar linkage fractured |2.4.G.1| | 1 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Rear fog lamp not working both lamps |1.3.2b| | 1 |
| Offside Front Drag link end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front Drag link end ball joint worn to the extent there is a serious risk of detachment |2.1.3 |b| |ii|| | 1 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Front Exhaust has a major leak of exhaust gases joint |7.1.2| | 1 |
| Offside Rear Sub-frame rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Windscreen has damage | 1 |
| Centre Rear Statutory seat belt missing |5.1.1| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Offside Front suspension has excessive movement at a suspension ball joint |2.5.A.1c| | 1 |
| Front Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Rear Vehicle structure has an inadequate repair which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering near road spring top. |6.1.A.1| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering behind front wheel section of floor and sill. |6.1.A.1| | 1 |
| Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering front of rear wheel area. |6.1.A.1| | 1 |
| Nearside Front Vehicle structure has excessive corrosion which adversely affects braking or steering near front wheel inside wheel arch area. |6.1.A.1| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Centre Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
| Driver`s door does not latch securely closed |6.2.B.1a| | 1 |
| Offside Rear fog lamp switch missing |1.3.1a| | 1 |
| Offside Front Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| front brakes release unevenly |3.7.B.4| | 1 |
| Nearside Rear Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front Power steering component|s| leaking |2.3.3b| | 1 |
| Nearside Rear Front drive shaft coupling has excessive play in a universal joint bearing |2.4.G.6b| | 1 |
| Nearside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Front Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Body or chassis has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Fuel cap/sealing device does not fasten securely by positive means |7.2.4b| | 1 |
| Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Headlamp insecure |1.7.3| | 1 |
| Nearside Front front brake binding |3.7.B.1| | 1 |
| An item not tested |Manual| | 1 |
| Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Suspension component mounting prescribed area is inadequately repaired |2.4.A.3| | 1 |
| Windscreen wiper not working (3.4 (a)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Side repeater incorrect colour n/s + o/s (4.4.3 (a)) | 1 |
| Anti-lock braking system warning lamp sequence is incorrect |3.4.1d| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Offside Front Brake hose leaking |3.6.A.1| | 1 |
| Offside Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Steering system excessively rough |2.2.D.1| | 1 |
| Direction indicators flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Front Sub-frame attachment rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Nearside front brake binding |3.7.B.1| | 1 |
| rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Lower Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Sub-frame rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Lower Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
| Nearside Rear Trailing arm severely distorted |2.4.G.1| | 1 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Exhaust engine idle speed too high |7.3.A.2a| | 1 |
| Offside Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Headlamp switch insecure |1.7.1| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Obligatory mirror missing |8.1.1| | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Front Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
| passenger door cannot be opened from outside the vehicle BOOT |6.2.B.1c| | 1 |
| Headlamp aim beam image obviously incorrect both front |1.8.A.1b| | 1 |
| Fuel system component leaking |7.2.3| | 1 |
| Body has a sharp edge caused by corrosion Both rear arches |6.1.C.1| | 1 |
| Nearside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Offside Front Upper Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Nearside Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Body or chassis has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Steering box has relative movement between sector shaft and the drop arm |2.2.B.1b| | 1 |
| Offside Front Vehicle structure has an inadequate repair, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Front Position lamp not working |4.2.1 |a| |ii|| | 1 |
| Windscreen washer not working | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 1 |