| Most common failures | No# failures |
|---|
| Brake pipe excessively corroded | 17 |
| Registration plate lamp issues | 10 |
| Parking brake: efficiency below requirements |3.7.B.7| | 9 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Rear parking brake recording little or no effort | 8 |
| Brake hose excessively deteriorated | 7 |
| Headlamp aim out of alignment | 6 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 6 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 5 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 4 |
| Offside Rear fog lamp not working |1.3.2b| | 4 |
| Rear brake binding | 4 |
| Brakes imbalanced across an axle | 3 |
| Horn not working |1.6.2a| | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Front brake disc in such a condition that it is seriously weakened | 3 |
| Exhaust system not adequately supported |7.1.1| | 2 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Fuel tank leaking |7.2.3| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Nearside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Vehicle structure inadequately repaired seriously affecting its strength within 30cm of towbar mounting |6.6.6| | 2 |
| Offside Headlamp insecure |1.7.3| | 2 |
| Driver`s seat insecure |6.2.A.1| | 2 |
| Nearside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Rear brake application uneven | 2 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 2 |
| Battery insecure |1.9.1| | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Brake load sensing valve linkage seized |3.6.E.3| | 2 |
| Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Outer Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Offside Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Brake load sensing valve inoperative and ABS not fitted or inoperative (1.1.17 (c) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Parking brake mechanism/associated mounting prescribed area is excessively corroded and functionality of the braking system is affected (1.1.21 (e) (ii)) | 1 |
| Nearside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Central Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced cross member at the rear (6.1.1 (c) (i)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Nearside Rear Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Nearside Rear Direction indicators adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Rear Direction indicators adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Front Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| All position lamps not working |4.2.1 |a|| | 1 |
| Offside Rear Service brake excessively binding |1.2.1 |f|| | 1 |
| Exhaust system insecure several rubber s missing |6.1.2 |a|| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Offside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Drivers door cannot be opened from inside the vehicle (6.2.3 (a)) | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect kick up wrong side (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect kick up wrong side (4.1.2 (c)) | 1 |
| Nearside Rear Leaf spring shackle pin or bush excessively worn rear spring bush (5.3.4 (a) (i)) | 1 |
| Offside Rear Leaf spring shackle pin or bush excessively worn rear spring bush (5.3.4 (a) (i)) | 1 |
| Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength 2 places (5.3.6 (a) (i)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Headlamp aim not tested |1.8.A.1c| | 1 |
| Service brake: efficiency below requirements |3.7.C.1a| | 1 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded outer sill |5.2.6| | 1 |
| Offside Inner Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Nearside Outer Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Nearside Inner Seat belt anchorage prescribed area is excessively corroded sill |5.2.6| | 1 |
| Nearside Front Inner Suspension spring mounting prescribed area is excessively corroded wing |2.4.A.3| | 1 |
| Offside Front Inner Suspension spring mounting prescribed area is excessively corroded wing |2.4.A.3| | 1 |
| Nearside Front Inner Suspension spring mounting prescribed area is inadequately repaired inner wing |2.4.A.3| | 1 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Electrical wiring inadequately supported tow bar |1.9.2a| | 1 |
| Offside Outer Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Lower Headlamp insecure |1.7.3| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Inner Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Inner Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Windscreen wiper not working |3.4 |a|| | 1 |
| Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Exhaust system insecure All rubber mounts broken (6.1.2 (a)) | 1 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Brake hydraulic reservoir fluid level below minimum level |3.6.G.1b| | 1 |
| Offside Rear wheel cylinder leaking |3.6.A.1| | 1 |
| Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Front Fuel system component leaking |7.2.3| | 1 |
| Front brake disc excessively scored |3.5.1h| | 1 |
| Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Headlamp insecure |1.7.3| | 1 |
| Power steering fluid level below minimum |2.3.1| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Brake cable has restricted free movement |3.5.1k| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Mechanical brake component has restricted free movement | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Position lamp switch faulty |1.1.A.1| | 1 |
| Front Headlamp not working on main beam |1.7.5a| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Rear Mechanical brake component has restricted free movement | 1 |
| Nearside Front Headlamp insecure |1.7.3| | 1 |
| Offside Front Front drive shaft damaged |2.5.C.2a| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 1 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Nearside Front Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Offside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Nearside Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Nearside Outer Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Rear Exhaust mounting missing |7.1.1b| | 1 |
| Nearside Inner Front Lower Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Nearside Front Headlamp aim so that beam "kick up" is not visible on the screen |4.1.2 |a|| | 1 |
| Nearside Rear Leaf spring shackle pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Leaf spring shackle pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Rear Upper Leaf spring shackle pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Upper Leaf spring shackle pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 1 |
| Offside Rear fog lamp adversely affected by the operation of another lamp |1.3.2f| | 1 |
| Offside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
| Rear Brake load sensing valve linkage seized |3.6.E.3| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Rear Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Offside Rear Shock absorber detached |2.7.2b| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Brake pipe leaking |3.6.A.1| | 1 |
| Windscreen has damage | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Front passenger seat insecure |6.2.3| | 1 |
| Brake pedal spongy |3.3.B.1b| | 1 |
| Offside Front Seat belt anchorage prescribed area is inadequately repaired |5.2.6| | 1 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Side repeater not working |1.4.A.2c| | 1 |
| Front Brake pipe inadequately supported |3.6.B.1| | 1 |
| Nearside Inner Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Nearside Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Rear Leaf spring anchor bracket corroded and seriously weakened |2.4.B.6d| | 1 |
| Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Front Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Nearside Front Suspension spring mounting prescribed area is excessively corroded |2.4.A.3| | 1 |