| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 17 |
| Parking brake: efficiency below requirements |3.7.B.7| | 13 |
| Brakes imbalanced across an axle | 10 |
| Registration plate lamp issues | 10 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 9 |
| Offside Rear fog lamp not working |1.3.2b| | 7 |
| Offside Steering rack gaiter insecure |2.2.D.2d| | 6 |
| Nearside Stop lamp not working |1.2.1b| | 5 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 5 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 4 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Rear parking brake recording little or no effort | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Horn not working |1.6.2a| | 4 |
| Parking brake lever has no reserve travel |3.1.6b| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
| Nearside Steering rack gaiter insecure |2.2.D.2d| | 3 |
| Battery insecure |1.9.1| | 3 |
| Windscreen washer not working | 2 |
| Nearside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 2 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Rear Fluid suspension unit leaking |2.4.D.2| | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 2 |
| Front brake application uneven | 2 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Nearside Front Body has a sharp edge caused by corrosion |6.1.C.1| | 2 |
| Offside front parking brake recording little or no effort |3.7.B.6a| | 2 |
| Nearside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Exhaust emissions hydrocarbon content excessive |7.3.B.1b| | 2 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 2 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
| Offside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 2 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Offside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front brake disc contaminated by oil |3.5.1h| | 1 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Exhaust emissions hydrocarbon content excessive (8.2.1.2 (b)) | 1 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Obligatory mirror missing |8.1.1| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Parking brake recording little or no effort |3.7.D.3a| | 1 |
| Nearside Front Braking system leaking |3.6.A.1| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front brake disc contaminated by grease |3.5.1h| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Offside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Rear Suspension component leaking (5.3.5 (c)) | 1 |
| Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Nearside Lower Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Offside Front Upper Brake prescribed area is excessively corroded (1.1.21 (e) (i)) | 1 |
| Offside Front Lower Seat belt anchorage prescribed area is inadequately repaired (7.1.1 (a) (i)) | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Offside Steering system has a road wheel fouling a part of the vehicle |2.2.D.2a| | 1 |
| Offside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded inner wheel arch |2.4.A.3| | 1 |
| Nearside Front Suspension component mounting prescribed area is inadequately repaired inner wheel arch |2.4.A.3| | 1 |
| Fluid suspension leaking |2.4.D.2| | 1 |
| Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
| Nearside Front Inner Suspension component mounting prescribed area is excessively corroded wheelarch |2.4.A.3| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Position lamp switch faulty |1.1.A.1| | 1 |
| Offside Front Lower Suspension arm pin or bush likely to become detached (5.3.4 (a) (ii)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Nearside Fluid suspension levelling valve insecure |2.4.D.4| | 1 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Steering rack insecure |2.2.B.1a| | 1 |
| Offside Steering rack insecure |2.2.B.1a| | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Battery insecure and likely to cause a short circuit (4.13 (a) (ii)) | 1 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Brake pipe excessively corroded | 1 |
| Exhaust emissions - engine idle speed too high (8.2.1.2 (e)) | 1 |
| Offside Front Outer Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Front Upper Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Position lamp adversely affected by the operation of another lamp (4.2.3 (c)) | 1 |
| Offside Front Direction indicator adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Exhaust engine idle speed too high |7.3.A.2a| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Headlamp not working on main beam |1.7.5a| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Front Fluid suspension unit leaking |2.4.D.2| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Front Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` wiper arm parking in zone A |8.3.1b| | 1 |
| Fluid suspension has no suspension movement front & rear |2.4.D.5| | 1 |
| Nearside Direction indicator not working front & rear |1.4.A.2c| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Headlamp aim so that beam "kick up" is not visible on the screen |1.8.B.1| | 1 |
| Offside Headlamp aim so that beam "kick up" is not visible on the screen |1.8.B.1| | 1 |
| Offside Rear Direction indicators not working when operated off side rear indicator illuminates near side reverse light |1.4.A.2c| | 1 |
| Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Stop lamp not working when stop light applied it puts out position light off side and lights up near side reverse light and near side fog light |1.2.1b| | 1 |
| Indicator tell tale inoperative |1.4.A.2a| | 1 |
| Towbar component insecure both front fixings have not been fitted |6.6.1| | 1 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc two outer gaters fitted each side |2.5.C.1a| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Brake pipe leaking |3.6.A.1| | 1 |
| Offside Rear Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
| Horn not working |7.7 |a| |ii|| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Inner Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Inner Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Windscreen has damage | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Front Inner Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
| Horn not working (7.7 (a)) | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Inner Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Front Inner Suspension arm has excessive play in a pin/bush Rear bush |2.4.G.2| | 1 |