| Most common failures | No# failures |
|---|
| Parking brake: efficiency below requirements |3.7.B.7| | 11 |
| Brake hose excessively deteriorated | 9 |
| Headlamp aim out of alignment | 9 |
| Registration plate lamp issues | 8 |
| Exhaust emissions carbon monoxide content excessive |7.3.B.1a| | 6 |
| Nearside front parking brake recording little or no effort |3.7.B.6a| | 4 |
| Windscreen wiper does not clear the windscreen effectively | 4 |
| Windscreen washer not working | 4 |
| Service brake: efficiency below requirements |3.7.B.7| | 4 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Brakes imbalanced across an axle | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Nearside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 2 |
| Offside Front Fluid suspension pipe leaking |2.4.D.2| | 2 |
| Offside front parking brake recording little or no effort |3.7.B.6a| | 2 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 2 |
| Fluid suspension pipe leaking |2.4.D.2| | 2 |
| Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
| Offside Steering rack gaiter split |2.2.D.2d| | 2 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 2 |
| Nearside Headlamp not working on main beam |1.7.5a| | 2 |
| Nearside Front Hydraulic brake calliper leaking (1.1.16 (b) (i)) | 1 |
| Offside Rear Suspension component leaking (5.3.5 (c)) | 1 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Brake pipe excessively corroded | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Outer Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Exhaust engine idle speed too high |7.3.A.2a| | 1 |
| Emissions not tested |7.0| | 1 |
| Horn not loud enough to be heard by another road user |1.6.2b| | 1 |
| Offside Front Fluid suspension leaking |2.4.D.2| | 1 |
| Offside Obligatory mirror insecure |8.1.1| | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Offside Rear Body has a sharp edge caused by corrosion |6.1.C.1| | 1 |
| Nearside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 1 |
| Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill |5.3.6 |a| |i|| | 1 |
| Hydraulic fluid leaking excessively |8.4.1 |a| |i|| | 1 |
| Fuel pipe leaking |6.1.3 |b| |i|| | 1 |
| Exhaust system insecure |6.1.2 |a|| | 1 |
| Exhaust emissions carbon monoxide content excessive (8.2.1.2 (b)) | 1 |
| Nearside Front Position lamp light intensity significantly reduced (4.2.3 (a) (ii)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill (7.1.1 (a) (i)) | 1 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Nearside Front Seat belt missing (7.1.2 (a)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 1 |
| Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings seal |6.1.B.2| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front Driver`s door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Fluid suspension unit leaking |2.4.D.2| | 1 |
| Offside Front Obligatory mirror does not provide a view to the rear (3.3 (c)) | 1 |
| Nearside Rear Seat belt buckle missing (7.1.2 (d)) | 1 |
| Nearside Rear Seat belt missing (7.1.2 (a)) | 1 |
| Offside Front All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Hydraulic fluid leaking continuously posing a serious risk to road safety sphere area (8.4.1 (a) (ii)) | 1 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Braking system leaking |3.6.A.1| | 1 |
| Offside Rear Subframe mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Brake lever has restricted free movement |3.5.1k| | 1 |
| Nearside Front Brake lever has abnormal movement of levers indicating excessive wear |3.5.1f| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Offside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
| Nearside Front Lower Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Brake performance not tested (1.2.1 (g)) | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Offside Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Brake pedal anti-slip provision missing (1.1.2 (c)) | 1 |
| Driver`s seat insecure |6.2.A.1| | 1 |
| Nearside Driver`s seat insecure |6.2.A.1| | 1 |
| Battery insecure |1.9.1| | 1 |
| Nearside Rear Fluid suspension leaking |2.4.D.2| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front Direction indicator not working |4.4.1 |a| |ii|| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Exhaust emissions carbon monoxide content excessive |8.2.1.2 |b|| | 1 |
| Offside Front Suspension component insecurely attached |5.3.3 |a| |i|| | 1 |
| Nearside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Fluid suspension pipe leaking |2.4.D.2| | 1 |
| Offside Rear Fluid suspension pipe leaking |2.4.D.2| | 1 |
| Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 1 |
| Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Front Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Braking system leaking |3.6.A.1| | 1 |
| Parking brake lever has no reserve travel |3.1.6b| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt Both front upper arm outer ball joint covers split. (5.3.4 (b) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt Upper arm mid ball joint cover. (5.3.4 (b) (ii)) | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt & off side front (2.1.3 (g) (ii)) | 1 |
| Offside Front Steering locking device ineffective track rod end lock nut loose (2.1.3 (d)) | 1 |
| Offside Front Lower Steering locking device missing ball joint locking tabs not pinged over (2.1.3 (d)) | 1 |
| Offside Rear Fluid suspension levelling valve leaking |2.4.D.2| | 1 |
| Nearside Rear Fluid suspension accumulator deteriorated and likely to fail |2.4.D.1b| | 1 |
| Nearside Front Headlamp not working on dipped beam with near side indicator on |1.7.5a| | 1 |
| Nearside Front Headlamp not working on main beam with near side indicator on |1.7.5a| | 1 |
| Nearside Front Direction indicator adversely affected by the operation of another lamp all near side lights |1.4.A.2h| | 1 |
| Spare wheel insecure rim under bonnet |6.4.2| | 1 |
| Fluid suspension leaking x4 leaks under car from around back of engine and offside centre floor and off side rear |2.4.D.2| | 1 |
| Offside Front Track rod end loose lock nut on hub |2.2.B.1d| | 1 |
| Offside Front front brake binding |3.7.B.1| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Suspension has inadequate clearance with the chassis wheel is rubbing inside inner of wheel arch |2.4.A.1a| | 1 |
| Indicator switch faulty |1.4.A.1| | 1 |
| Nearside Headlamp missing |1.7.3| | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front All direction indicators not working |4.4.1 |a| |ii|| | 1 |
| Exhaust emissions hydrocarbon content excessive engine misfiring hc reading 3275ppm |8.2.1.2 |b|| | 1 |
| Nearside Hydraulic fluid leaking excessively |8.4.1 |a| |i|| | 1 |
| Nearside Front Suspension component leaking suspension fluid running down near side chassis rail |5.3.5 |c|| | 1 |