| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 367 |
| Parking brake: efficiency below requirements |3.7.B.7| | 345 |
| Windscreen wiper does not clear the windscreen effectively | 314 |
| Headlamp aim out of alignment | 233 |
| Rear parking brake recording little or no effort | 214 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 213 |
| Offside Stop lamp not working |1.2.1b| | 127 |
| Nearside Stop lamp not working |1.2.1b| | 104 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 100 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 92 |
| Parking brake lever has no reserve travel |3.1.6b| | 86 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 71 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 70 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 67 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 63 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 62 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 59 |
| Brakes imbalanced across an axle | 58 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 57 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 57 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 55 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 51 |
| Exhaust system not adequately supported |7.1.1| | 51 |
| Rear Exhaust system not adequately supported |7.1.1| | 50 |
| Rear brake binding | 49 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 47 |
| Offside Rear Stop lamp not working |1.2.1b| | 44 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 44 |
| Nearside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 42 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 41 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 37 |
| Nearside Rear Stop lamp not working |1.2.1b| | 37 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 37 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 36 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 36 |
| Windscreen washer not working | 36 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 32 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 32 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 31 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 31 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 29 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 29 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 29 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 28 |
| Offside Front coil spring broken |2.4.C.1a| | 27 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 27 |
| Anti-lock braking system warning lamp indicates an ABS fault | 27 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 27 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 26 |
| Nearside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 26 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 25 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 25 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 25 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 24 |
| Centre Exhaust system not adequately supported |7.1.1| | 24 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 24 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 24 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 23 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 23 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 23 |
| Brake pipe excessively corroded | 22 |
| Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 22 |
| Front brake disc in such a condition that it is seriously weakened | 22 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 22 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 21 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 21 |
| Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 21 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 21 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 21 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 21 |
| Registration plate issues | 21 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 20 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 20 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 20 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 20 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 20 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 20 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 19 |
| Nearside Front coil spring broken |2.4.C.1a| | 19 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 19 |
| Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 19 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 19 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 19 |
| Brake pedal anti-slip provision missing |3.3.A.1b| | 18 |
| Offside Front Position lamp not working |4.2.1 |a|| | 18 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 18 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 18 |
| Offside Rear Coil spring fractured or broken (5.3.1 (b) (i)) | 18 |
| Windscreen wiper blade insecure | 17 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 17 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 17 |
| Exhaust system insecure (6.1.2 (a)) | 17 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 16 |
| Offside Parking brake inoperative on one side |1.4.1 |a|| | 16 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 16 |
| Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 16 |
| Power steering fluid level below minimum |2.3.1| | 15 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 15 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 14 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 14 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 14 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 14 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 13 |
| Offside Rear Stop lamp|s| not working |4.3.1 |a| |ii|| | 13 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 13 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 13 |
| Rear Exhaust system insecure (6.1.2 (a)) | 13 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 13 |
| Offside Front Upper Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 13 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 12 |
| Offside Side repeater incorrect colour |1.4.A.2f| | 12 |
| Windscreen has damage | 12 |
| Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 12 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 12 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 12 |
| Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 12 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 11 |
| Service brake: efficiency below requirements |3.7.B.7| | 11 |
| Exhaust emits excessive smoke or vapour of any colour |7.4.B.4| | 11 |
| Offside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 11 |
| Parking brake lever insecure |3.1.3b| | 11 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 11 |
| rear parking |secondary| brakes imbalanced | 11 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 11 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 11 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 11 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 11 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 11 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 11 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 11 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 10 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 10 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 10 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 10 |
| Rear Mechanical brake component has restricted free movement | 10 |
| Nearside Side repeater incorrect colour |1.4.A.2f| | 10 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 10 |
| Nearside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 10 |
| Nearside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 10 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 10 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 10 |
| Exhaust emits an excessive level of metered smoke |7.4.B.3a| | 9 |
| Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 9 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i)) | 9 |
| Offside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 9 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 9 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 9 |
| Offside Upper Rear position lamp|s| not working |1.1.A.3b| | 9 |
| Front brake application uneven | 9 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 9 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 9 |
| Nearside Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 9 |
| Offside Front Coil spring fractured or broken |5.3.1 |b| |i|| | 9 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 9 |
| Nearside Rear Other passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 9 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 9 |