Most common failures | No# failures |
---|
Headlamp aim out of alignment | 18 |
Registration plate lamp issues | 9 |
Parking brake: efficiency below requirements |3.7.B.7| | 8 |
Windscreen wiper does not clear the windscreen effectively | 8 |
Brakes imbalanced across an axle | 7 |
Horn not working |1.6.2a| | 5 |
Offside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
Nearside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
Nearside Headlamp not working on dipped beam |1.7.5a| | 4 |
Offside Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 4 |
Nearside Front Direction indicator not working |1.4.A.2c| | 3 |
Nearside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 3 |
Direction indicators not working |1.4.A.2c| | 3 |
Service brake: efficiency below requirements |3.7.B.7| | 3 |
Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
Rear parking brake recording little or no effort | 3 |
Nearside rear brake recording little or no effort |3.7.B.5a| | 3 |
Offside rear brake recording little or no effort |3.7.B.5a| | 3 |
Parking brake lever has no reserve travel |3.1.6b| | 3 |
Windscreen washer not working | 3 |
Offside Stop lamp not working |1.2.1b| | 3 |
Registration plate issues | 3 |
Indicator tell tale inoperative |1.4.A.2a| | 2 |
Offside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
Nearside Front Headlamp not working on main beam |1.7.5a| | 2 |
Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 2 |
Offside Direction indicator not working |1.4.A.2c| | 2 |
Exhaust system not adequately supported |7.1.1| | 2 |
Nearside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Brake pipe excessively corroded | 2 |
Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
Offside Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 2 |
Rear fog lamp not working |1.3.2b| | 2 |
Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
Offside Rear Shock absorbers has a serious fluid leak | 2 |
Offside Rear Direction indicators not working |1.4.A.2c| | 2 |
Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 2 |
Offside Headlamp not working on dipped beam |1.7.5a| | 2 |
Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
Offside Headlamp not working on main beam |1.7.5a| | 2 |
Nearside Headlamp not working on main beam |1.7.5a| | 1 |
Nearside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Headlamp switch insecure |1.7.1| | 1 |
Nearside Headlamp aim beam image kick up to the offside |1.8| | 1 |
Nearside Side repeater not working |1.4.A.2c| | 1 |
Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Nearside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
Steering pivot point has excessive play |2.2.B.1g| | 1 |
Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced |6.1.1 |c| |i|| | 1 |
Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
Rear Mechanical brake component has restricted free movement | 1 |
Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced Drivers Belt mount (7.1.1 (a) (i)) | 1 |
Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i)) | 1 |
Nearside Rear Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Offside Side repeater not working |1.4.A.2c| | 1 |
Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
Front Indicator tell tale inoperative |1.4.A.2a| | 1 |
Front Parking brake lever has no reserve travel |3.1.6b| | 1 |
Offside Front Brake pipe leaking |3.6.A.1| | 1 |
Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Side repeater not working |1.4.A.2c| | 1 |
Offside Front Side repeater not working |1.4.A.2c| | 1 |
Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement |7.2.4b| | 1 |
Nearside Inner Rear Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
Offside Rear Direction indicator excessively deteriorated so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
Offside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Fuel pipe insecure |7.2.1| | 1 |
Nearside Front Road wheel bead rim badly distorted |4.2.A.1a| | 1 |
Nearside Upper Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
Nearside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Front brake disc contaminated by oil |3.5.1h| | 1 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 1 |
Front suspension retaining device ineffective front axle and rear axle |2.5.A.4| | 1 |
Driver`s seat insecure |6.2.A.1| | 1 |
Battery insecure |1.9.1| | 1 |
Front Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Offside Headlamp aim projected beam image is obviously incorrect dipping to right (4.1.2 (c)) | 1 |
Offside Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Nearside Axle king pin is loose in the axle beam (5.1.2 (d) (i)) | 1 |
Offside Axle king pin is loose in the axle beam (5.1.2 (d) (i)) | 1 |
Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Centre Rear Vehicle structure has an unsatisfactory modification, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Rear Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings floor |6.1.B.2| | 1 |
Nearside Front Axle swivel pins and bushes swivel pin and/or bush excessively worn (5.1.2 (b) (i)) | 1 |
Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
Central Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
Nearside Front Suspension arm insecurely attached (5.3.3 (a) (i)) | 1 |
Parking brake lever defective so that it cannot be satisfactorily operated (1.1.6 (d)) | 1 |
Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i)) | 1 |
Nearside Headlamp lens missing (4.1.1 (b) (ii)) | 1 |
Parking brake inoperative on one side (1.4.1 (a)) | 1 |
All direction indicators not working (4.4.1 (a) (ii)) | 1 |
Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
Nearside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Nearside Rear Stop lamp not working |1.2.1b| | 1 |
Nearside Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
Nearside Front Road wheel fractured |4.2.B.1a| | 1 |
Rear Exhaust system not adequately supported |7.1.1| | 1 |
Offside Inner Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Hydraulic brake cylinder leaking hydraulic fluid (1.1.16 (b) (i)) | 1 |
Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) | 1 |
Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
Service brake efficiency less than 50% of the required value |1.2.2 |a| |ii|| | 1 |
Nearside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Offside Front Seat belt insecurely fixed to the vehicles structure |5.2.1a| | 1 |
Front Seat belt insecurely fixed to the vehicles structure buckle bolt loose |5.2.1a| | 1 |
Offside Front Shock absorber has an excessively worn linkage |2.7.4| | 1 |
Offside Rear Shock absorber casing corroded externally so the unit does not function |2.7.2a| | 1 |
Nearside Headlamps matched pair are not the same colour |1.7.6| | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
Front Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone `A` |8.3.1b| | 1 |
Front Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
Nearside Exhaust system not adequately supported |7.1.1| | 1 |
Nearside Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Offside rear brake grabbing severely |3.7.A.5b| | 1 |
Nearside rear brake juddering severely |3.7.A.5b| | 1 |
Offside rear brake juddering severely |3.7.A.5b| | 1 |
Brake pedal has insufficient reserve movement |3.3.A.5| | 1 |
Offside Front Direction indicator not working |1.4.A.2c| | 1 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Suspension component mounting prescribed area is excessively corroded |2.4.A.3| | 1 |
Nearside Steering component mounting prescribed area is excessively corroded |2.2.C.1h| | 1 |
Nearside Front Brake pipe inadequately supported |3.6.B.1| | 1 |
Passengers seat insecure (6.2.6 (a) (ii)) | 1 |
Offside Front Other passenger door cannot be opened from outside the vehicle |6.2.3 |a|| | 1 |
Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
Nearside Stop lamp not working |1.2.1b| | 1 |
Nearside Rear Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Nearside Rear Shock absorber has negligible damping effect |2.7.5| | 1 |
Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Brake master cylinder insecurely mounted |3.6.G.1a| | 1 |
Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
Offside front parking brake recording little or no effort |3.7.B.6a| | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Nearside Front Headlamp insecure |1.7.3| | 1 |
Offside Front Headlamp insecure |1.7.3| | 1 |
Offside Front Axle king pin has excessive play in pin and/or bush adversely affecting the steering |2.5.A.3a| | 1 |
Centre Exhaust system not adequately supported |7.1.1| | 1 |
Fuel hose excessively damaged |7.2.2| | 1 |
Nearside Front Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
Inner Front Drive shaft which forms part of the suspension coupling gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.4.G.4e| | 1 |
Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Position lamp switch faulty |1.1.A.1| | 1 |
Nearside Body has a projection caused by damage |6.1.C.1| | 1 |
Nearside Vehicle structure has excessive corrosion which adversely affects braking or steering |6.1.A.1| | 1 |
Windscreen wiper not working |3.4 |a|| | 1 |
Indicator switch inoperative |4.4.2 |a| |ii|| | 1 |
Offside Front Seat belt retracting mechanism defective |7.1.2 |e|| | 1 |
Rear Other passenger door does not latch securely closed |6.2.3 |a|| | 1 |
All position lamps light intensity significantly reduced |4.2.3 |a| |ii|| | 1 |
Nearside Front Axle swivel pins and bushes swivel pin and/or bush excessively worn kingpin |5.1.2 |b| |i|| | 1 |
Offside Front Axle swivel pins and bushes swivel pin and/or bush excessively worn kingpin |5.1.2 |b| |i|| | 1 |
Nearside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
All direction indicators not working |4.4.1 |a| |ii|| | 1 |
Offside Rear Position lamp not working |4.2.1 |a|| | 1 |
Offside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
Offside Rear Electrical wiring insecure and connectors likely to become disconnected |4.11 |a| |ii|| | 1 |
Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded |3.6.C.3| | 1 |
Horn not working |7.7 |a| |ii|| | 1 |
Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
Offside Front Position lamp not working |4.2.1 |a|| | 1 |
Windscreen wiper not working (3.4 (a)) | 1 |
Nearside Front Brake pipe leaking on a hydraulic braking system ON MASTER CYLINDER (1.1.11 (b) (ii)) | 1 |
Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Nearside Front Lower Suspension component pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Lower Suspension component pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
Offside Rear Shock absorbers has an excessively worn bush (5.3.2 (c)) | 1 |
Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Body or chassis is damaged, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |