| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 22 |
| Registration plate issues | 19 |
| Registration plate lamp issues | 16 |
| Windscreen wiper does not clear the windscreen effectively | 16 |
| Offside Headlamp aim beam image kick up to the offside |1.8| | 15 |
| Parking brake lever has no reserve travel |3.1.6b| | 13 |
| Nearside Headlamp aim beam image kick up to the offside |1.8| | 11 |
| Nearside Rear Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 7 |
| Nearside Stop lamp not working |1.2.1b| | 7 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 7 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 7 |
| Offside Front Headlamp aim beam image kick up to the offside |1.8| | 7 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.8| | 6 |
| Parking brake: efficiency below requirements |3.7.B.7| | 5 |
| Offside Rear Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 5 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 5 |
| Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 5 |
| Front brake disc in such a condition that it is seriously weakened | 4 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Offside Stop lamp not working |1.2.1b| | 3 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 3 |
| Brakes imbalanced across an axle | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Rear fog lamp tell tale not working |1.3.1b| | 3 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Anti-lock braking system warning lamp indicates an ABS fault | 3 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
| Nearside Side repeater not working |1.4.A.2c| | 3 |
| Offside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 3 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 2 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Horn not working |1.6.2a| | 2 |
| Rear fog lamp not working |1.3.2b| | 2 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 2 |
| Offside Headlamp not working on main beam |1.7.5a| | 2 |
| Offside Front coil spring broken |2.4.C.1a| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 2 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 2 |
| Rear fog lamp missing |1.3.2a| | 2 |
| Rear fog lamp switch missing |1.3.1a| | 2 |
| Nearside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 2 |
| Nearside Headlamp aim beam image kick up to the offside |1.6.B1| | 2 |
| Offside Headlamp aim beam image kick up to the offside |1.6.B1| | 2 |
| Rear fog lamp not visible from a reasonable distance |1.1.6b| | 1 |
| Brake master cylinder leaking hydraulic fluid |3.6.G.1f| | 1 |
| Front Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Centre Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Nearside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Front position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Offside Headlamp aim not tested |1.8.A.1c| | 1 |
| Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Offside Front Coil spring fractured or broken (5.3.1 (b) (i)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b)) | 1 |
| Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc inner |2.5.C.1a| | 1 |
| Rear Stop lamp(s) all not working (4.3.1 (a) (iii)) | 1 |
| Brake pipe excessively corroded | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Front Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Front coil spring fractured |2.4.C.1a| | 1 |
| Nearside Inner Front Steering system has excessive free play detected at the steering wheel |steering rack fitted| |2.2.A.1b| | 1 |
| Front Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Offside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Brake hose excessively deteriorated | 1 |
| Bonnet retaining device excessively deteriorated |8.4.2| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Rear parking brake recording little or no effort | 1 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Rear Shock absorber detached |2.7.2b| | 1 |
| Nearside Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
| Offside Front Track rod end ball pin shank loose |2.2.B.1c| | 1 |
| Brake hose has insufficient room to move | 1 |
| Nearside Front Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Offside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Offside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Upper Ball joint has excessive play |2.2.B.1f| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| Headlamp aim beam image kick up to the offside |1.8| | 1 |
| Brake hose damaged | 1 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 1 |
| Nearside Front Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Rear wheel bearing rough when rotated |2.6.1| | 1 |
| Parking (secondary brake) on a single line braking system grabbing severely (1.3.1 (c)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Nearside Front position lamp|s| not in good working order |function impaired| |1.1.4a| | 1 |
| Offside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Rear brake binding | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Rear Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear Upper Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front suspension has a suspension lower ball joint securing nut not locked |2.5.B.1a| | 1 |
| Offside Front suspension has a suspension lower ball joint securing nut not locked |2.5.B.1a| | 1 |
| Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Offside Front Side repeater incorrect colour |1.4.A.2f| | 1 |
| Front Exhaust has a major leak of exhaust gases manifold area |7.1.2| | 1 |
| Nearside Front Lower Suspension arm locating pin locking device missing |2.4.G.3b| | 1 |
| Offside Front Lower Suspension arm locating pin locking device missing |2.4.G.3b| | 1 |
| Nearside Rear Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Rear Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Side repeater not working |1.4.A.2c| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Outer Rear Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Nearside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Nearside Rear Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Rear Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Rear Upper Suspension arm has excessive play in a pin/bush Both sides |2.4.G.2| | 1 |
| Side repeater missing |1.4.A.2b| | 1 |
| Offside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Front Obligatory mirror missing |8.1.1| | 1 |
| Offside Rear fog lamp missing |1.3.2a| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Side repeater not working (4.4.1 (a) (ii)) | 1 |
| Offside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Rear Upper Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Rear Rear fog lamp not working |1.3.2b| | 1 |
| Centre Stop lamp not working |1.2.1b| | 1 |
| Nearside Outer Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Front Upper Front suspension has excessive movement at a wishbone pin or bush |2.5.A.1c| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Nearside Inner Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Inner Rear brake disc excessively pitted |3.5.1h| | 1 |
| Headlamp aim projected beam image is obviously incorrect both (4.1.2 (c)) | 1 |
| Nearside Front Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Offside Front Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Front Service brake juddering severely |3.7.C.2| | 1 |