| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 23 |
| Registration plate lamp issues | 14 |
| Brake pipe excessively corroded | 13 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 6 |
| Offside Rear fog lamp not working |1.3.2b| | 6 |
| Rear Exhaust system not adequately supported |7.1.1| | 5 |
| Parking brake lever has no reserve travel |3.1.6b| | 4 |
| Windscreen has damage | 3 |
| Headlamp aim out of alignment | 3 |
| Front brake disc in such a condition that it is seriously weakened | 3 |
| Offside Stop lamp not working |1.2.1b| | 2 |
| Anti-lock braking system warning lamp indicates an ABS fault | 2 |
| Nearside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Brakes imbalanced across an axle | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Front Steering damper leaking oil |2.2.C.1f| | 2 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Centre Stop lamp not working |1.2.1b| | 2 |
| Offside Rear fog lamp emits a light other than red |1.3.2e| | 2 |
| Nearside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Rear parking brake recording little or no effort | 2 |
| Battery insecure |1.9.1| | 2 |
| Parking brake: efficiency below requirements |3.7.B.7| | 2 |
| Service brake: efficiency below requirements |3.7.B.7| | 2 |
| Centre Rear Stop lamp not working |1.2.1b| | 2 |
| Rear Fuel hose leaking |7.2.3| | 1 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 1 |
| Exhaust emissions carbon monoxide content after 2nd fast idle excessive |7.3.D.3| | 1 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 1 |
| Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Direction indicator not working inner ? |1.4.A.2c| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Headlamp excessively damaged so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front brake disc excessively pitted |3.5.1h| | 1 |
| Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Nearside Windscreen wiper blade deteriorated |8.2.2| | 1 |
| Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front brake excessively fluctuating | 1 |
| Nearside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
| Nearside All direction indicators adversely affected by the operation of another lamp (4.4.3 (b)) | 1 |
| Registration plate issues | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Windscreen wiper not operating automatically when switched on |8.2.1b| | 1 |
| Rear fog lamp tell tale not working |1.3.1b| | 1 |
| Nearside Rear position lamp|s| incomplete |1.1.4a| | 1 |
| Exhaust system not adequately supported REAR BRACKET SNAPPED |7.1.1| | 1 |
| Nearside rear brake recording little or no effort |3.7.B.5a| | 1 |
| Steering locking device insecure |2.2.C.1g| | 1 |
| Front Intermediate drop arm insecure |2.2.B.1a| | 1 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 1 |
| Windscreen washer not working | 1 |
| All direction indicators not working (4.4.1 (a) (ii)) | 1 |
| Nearside Rear Stop lamp(s) not working and centre (4.3.1 (a) (ii)) | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Fluid leak harmful to the environment or a risk to other road users steering damper (8.4.1 (a) (i)) | 1 |
| Brake pedal anti-slip provision incomplete |3.3.A.1b| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Offside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Brake hose excessively deteriorated | 1 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Headlamp aim beam image kick up to the offside |1.6.B1| | 1 |
| Offside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Nearside Front Seat belt anchorage prescribed area is excessively corroded |5.2.6| | 1 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Offside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear fog lamp does not emit a steady red light |1.3.2e| | 1 |
| Power steering pipe|s| or hose|s| fouling other parts of the vehicle |2.3.2| | 1 |
| Offside Front brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear Rear fog lamp emits a light other than red |1.3.2e| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Offside Front Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Torque/reaction arm has a deteriorated rubber bush resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Torque/reaction arm has a deteriorated rubber bush resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Stop lamp(s) light intensity significantly reduced (4.3.3 (a) (ii)) | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Upper Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Obligatory mirror missing (3.3 (a)) | 1 |
| Drivers view of the road through the swept area of the windscreen significantly affected by an obstruction internal condensataion (3.1 (a) (ii)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Parking brake lever has excessive movement indicating incorrect adjustment |1.1.6 |c|| | 1 |
| Nearside Headlamp levelling device inoperative |4.1.5 |a|| | 1 |
| Brake fluid contaminated |1.8 |a|| | 1 |
| Nearside Headlamp insecure |4.1.1 |c|| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Nearside Rear Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Central Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Horn not working |1.6.2a| | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Rear rear brake recording little or no effort |3.7.B.5a| | 1 |
| Nearside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Steering system has excessive free play detected at the steering wheel |steering box fitted| |2.2.A.1a| | 1 |
| Nearside Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Front constant velocity joint is insecure |2.5.C.1b| | 1 |
| Offside Front Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Nearside Front Lower Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Brake performance not tested |3.7.A.1| | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |