| Most common failures | No# failures |
|---|
| Windscreen wiper does not clear the windscreen effectively | 61 |
| Parking brake: efficiency below requirements |3.7.B.7| | 44 |
| Rear parking brake recording little or no effort | 36 |
| Anti-lock braking system warning lamp indicates an ABS fault | 33 |
| Registration plate lamp issues | 30 |
| Brake pipe excessively corroded | 24 |
| Headlamp aim out of alignment | 14 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 13 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 11 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 9 |
| Registration plate issues | 7 |
| Centre Stop lamp not working |1.2.1b| | 7 |
| Parking brake lever has no reserve travel |3.1.6b| | 7 |
| Nearside Stop lamp not working |1.2.1b| | 6 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 6 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 5 |
| Front brake disc in such a condition that it is seriously weakened | 5 |
| Brakes imbalanced across an axle | 4 |
| Centre Rear Stop lamp not working |1.2.1b| | 4 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Battery insecure |1.9.1| | 4 |
| Brake hose excessively deteriorated | 3 |
| Nearside Side repeater not working |1.4.A.2c| | 3 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Rear Wheel nut|s| missing |4.2.A.1e| | 3 |
| Rear brake binding | 3 |
| Exhaust emissions Lambda reading after 2nd fast idle outside specified limits |7.3.D.3| | 3 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 3 |
| Rear Exhaust has a major leak of exhaust gases |7.1.2| | 3 |
| Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Rear fog lamp tell tale not working |1.3.1b| | 2 |
| Nearside Rear Direction indicator incorrect colour (4.4.3 (a)) | 2 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 2 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 2 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Upper Stop lamp not working |1.2.1b| | 2 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Fuel tank leaking (6.1.3 (b) (i)) | 2 |
| Central Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
| Emissions not tested |7.0| | 2 |
| Nearside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Side repeater not working |1.4.A.2c| | 2 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 2 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 2 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 2 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 2 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Offside Rear Body has a sharp edge caused by damage bumper |6.1.C.1| | 2 |
| Mechanical brake component has restricted free movement | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Front Steering pivot point has excessive play |2.2.B.1g| | 2 |
| Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Front Side repeater missing |1.4.A.2b| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Rear fog lamp switch missing |1.3.1a| | 1 |
| Offside Direction indicator flashing more than 120 times a minute |1.4.A.2g| | 1 |
| Exhaust emissions likely to be affected by an exhaust leak |8.2.2.1 |b|| | 1 |
| Exhaust has a major leak of exhaust gases 3 places |6.1.2 |a|| | 1 |
| Brake cable damaged corroded |centre| |1.1.15 |a|| | 1 |
| Nearside Steering linkage ball joint has excessive play (inner rack joint) (2.1.3 (b) (i)) | 1 |
| Offside Rear Brake pipe inadequately clipped |3.6.B.1| | 1 |
| Exhaust shield missing where fitted as original equipment creating a risk of fire rear section (6.1.3 (e)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Front Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Exhaust carbon monoxide content after 2nd fast idle exceeds default limits (8.2.1.2 (b)) | 1 |
| Service brake efficiency below requirements (1.2.2 (a) (i)) | 1 |
| Central Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| rear parking |secondary| brakes imbalanced | 1 |
| Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Parking brake lever releases when knocked |3.1.6a| | 1 |
| Steering lock fails to engage |2.1.4b| | 1 |
| Hazard warning switch faulty not working |1.4.B.1d| | 1 |
| Offside Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Nearside Front suspension has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
| Offside Front suspension has excessive play in a track control arm inner bush |2.5.B.2b| | 1 |
| Nearside Power steering component|s| leaking from a failed joint |2.3.3b| | 1 |
| Nearside Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Emissions not tested no oil |8.2.1.2 |d|| | 1 |
| Nearside Rear Direction indicator incorrect colour |4.4.3 |a|| | 1 |
| Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
| Offside Front Wheel bearing has excessive play |5.1.3 |a| |i|| | 1 |
| Front Windscreen wiper blade missing |8.2.2| | 1 |
| Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Rear Stop lamp emits other than a steady red light |1.2.1e| | 1 |
| Nearside Front brake disc excessively scored |3.5.1h| | 1 |
| Offside Front brake disc excessively scored |3.5.1h| | 1 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Windscreen has damage | 1 |
| Rear Fuel system component defective in the case of LPG/CNG/ LNG or hydrogen systems LPG fuel tank corroded (6.1.3 (f)) | 1 |
| Offside Front Emergency exit window cannot be opened from inside the vehicle (9.1.2 (a)) | 1 |
| Rear brake application uneven | 1 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front Lower Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Service brake: efficiency below requirements |3.7.B.7| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 1 |
| Offside Front Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Side repeater not working |1.4.A.2c| | 1 |
| Hazard warning switch faulty |1.4.B.1d| | 1 |
| Hazard warning switch inoperative (4.4.2 (a) (ii)) | 1 |
| Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a)) | 1 |
| Offside Rear Direction indicators incorrect colour |1.4.A.2f| | 1 |
| Exhaust emissions likely to be affected by an exhaust leak centre box |8.2.1.1 |b|| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits |8.2.1.2 |c|| | 1 |
| Exhaust has a major leak of exhaust gases centre box |6.1.2 |a|| | 1 |
| Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i)) | 1 |
| Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill panel (5.3.6 (a) (i)) | 1 |
| Engine MIL inoperative or indicates a malfunction engine light on (8.2.1.2 (h)) | 1 |
| Windscreen washer not working | 1 |
| Engine MIL inoperative or indicates a malfunction light on (8.2.1.2 (h)) | 1 |
| Nearside Rear Upper Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Offside Rear Upper Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 1 |
| Nearside Front Shock absorber has negligible damping effect |2.7.5| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Passenger`s seat insecure |6.2.A.1| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Central Stop lamp not working |1.2.1b| | 1 |
| Direction indicator incorrect colour both rear |1.4.A.2f| | 1 |
| Rear Stop lamp not working middle |1.2.1b| | 1 |
| Driver`s airbag obviously defective |5.4.1| | 1 |
| Rear brake disc in such a condition that it is seriously weakened | 1 |
| Nearside Rear Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush |2.4.B.2| | 1 |
| Rear fog lamp switch insecure |1.3.1a| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Front Windscreen wiper control is inaccessible to the driver |8.2.1a| | 1 |
| Nearside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Offside Front Steering rack gaiter insecure |2.2.D.2d| | 1 |
| Nearside Inner Front Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Front Steering lock stop insecurely locked |2.2.D.2c| | 1 |
| Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Wheel nut|s| missing |4.2.A.1e| | 1 |
| Power steering fluid level below minimum |2.3.1| | 1 |
| Power steering component|s| leaking |2.3.3b| | 1 |
| Rear Rear fog lamp missing |1.3.2a| | 1 |
| Nearside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Rear position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Offside Front position lamp|s| incorrect colour |1.1.A.3e| | 1 |
| Nearside Side repeater missing |1.4.A.2b| | 1 |
| Offside Side repeater insecure |1.4.A.2b| | 1 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Offside Headlamp aim aimed so that it dazzles other road users |1.8.A.1a| | 1 |
| Front brake application uneven | 1 |
| Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength |5.3.6 |a| |i|| | 1 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Emissions not tested |7.3.A.1| | 1 |
| Exhaust system not adequately supported tail section missing and cant test emissions |7.1.1| | 1 |
| Fuel cap/sealing device ineffective |6.1.3 |b| |i|| | 1 |
| Nearside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Offside Headlamp light intensity severely reduced (4.1.4 (a)) | 1 |
| Nearside Rear Stop lamp(s) emits other than a steady red light (4.3.3 (a) (ii)) | 1 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Headlamp light intensity severely reduced lense faded (4.1.4 (a)) | 1 |
| Offside Headlamp light intensity severely reduced lense faded (4.1.4 (a)) | 1 |
| Offside Rear Position lamp has a product on the lens or light source which shows white light to the rear lense broke (4.2.3 (b) (ii)) | 1 |
| Front Power steering component|s| leaking steering rack near side |2.3.3b| | 1 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn drop link (5.3.4 (a) (i)) | 1 |
| Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt drop link (5.3.4 (b) (ii)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt Needs clip (6.1.7 (g) (ii)) | 1 |
| Offside Rear Parking brake is not capable of being maintained in operation by direct mechanical action only |3.1.2| | 1 |
| Service brake: efficiency below requirements |3.7.D.4| | 1 |
| Parking brake: efficiency below requirements |3.7.D.4| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Electronic parking brake control insecure |3.1.3b| | 1 |
| Electronic parking brake control is located so that it cannot be satisfactorily operated from the driver`s seat |3.1.3c| | 1 |
| Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 1 |
| Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
| Main beam tell-tale not working |4.9.1 |a| |ii|| | 1 |
| Nearside Front Anti-roll bar ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Parking |secondary brake| on a single line braking system has inadequate effort at a wheel |1.3.1 |a| |i|| | 1 |
| Nearside Service brake excessively binding |1.2.1 |f|| | 1 |
| Offside Service brake excessively binding |1.2.1 |f|| | 1 |
| Rear fog lamp not working |1.3.2b| | 1 |
| Central Rear Stop lamp not working |1.2.1b| | 1 |
| Offside Rear Rear wheel bearing has excessive play |2.6.2| | 1 |
| Brake fluid warning lamp illuminated |3.6.G.2| | 1 |
| Nearside Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting outer sill (6.2.2 (d) (i)) | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Steering linkage ball joint has excessive play rack arm (2.1.3 (b) (i)) | 1 |
| Nearside Front Brake hose excessively twisted (1.1.12 (b) (ii)) | 1 |
| Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Nearside Front Suspension rod ball joint dust cover no longer prevents the ingress of dirt drop link (5.3.4 (b) (ii)) | 1 |
| Central Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 1 |
| Offside Front Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front wheel bearing has excessive play |2.5.A.3c| | 1 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
| Windscreen in an unacceptable condition |3.2 |c| |i|| | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect |4.1.2 |c|| | 1 |
| Offside Front Obligatory mirror missing |8.1.1| | 1 |
| Nearside Front Direction indicators not working |1.4.A.2c| | 1 |
| Offside Front Direction indicators not working |1.4.A.2c| | 1 |
| Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Offside Rear Direction indicators not working |1.4.A.2c| | 1 |
| Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 1 |
| Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 1 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Front Front passenger door cannot be opened from inside the vehicle |6.2.B.1b| | 1 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Nearside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
| Centre Rear Seat belt locking mechanism does not secure or release stalk |5.2.5a| | 1 |
| Offside Front Inner Drag link end ball joint has excessive play trackrod |2.2.B.1f| | 1 |
| Anti-lock braking system warning lamp sequence is incorrect |3.4.1d| | 1 |
| Nearside Inner Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Inner Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Rear Wheel bearing rough when rotated |5.1.3 |b| |i|| | 1 |
| Nearside Rear Braking system leaking between brake pipe and calliper |3.6.A.1| | 1 |
| Windscreen wiper blade insecure | 1 |
| Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Bonnet retaining device excessively deteriorated |8.4.2| | 1 |
| Nearside Front front brake juddering severely |3.7.A.2b| | 1 |
| Offside Front front brake juddering severely |3.7.A.2b| | 1 |
| Nearside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Rear brake disc excessively pitted |3.5.1h| | 1 |
| Offside Front Road wheel badly damaged |4.2.A.1a| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Anti-lock braking system warning lamp is missing. |3.4.1a| | 1 |
| Nearside Ball joint has excessive play inner tie bar |2.2.B.1f| | 1 |
| Offside Ball joint has excessive play inner tie bar |2.2.B.1f| | 1 |
| Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Rear fog lamp tell-tale not working (4.9.1 (a) (ii)) | 1 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 1 |
| Offside passenger door hinge insecure |6.2.B.2| | 1 |
| All position lamps adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
| Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
| Front Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Front Steering rack has excessive free play detected at the steering wheel (steering rack fitted) (2.3 (a) (i)) | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Upper Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Nearside Rear Rear reflector defective or damaged by more than 50% of the reflecting surface |4.8.1 |a| |ii|| | 1 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Rear fog lamp emits a light other than red lens broken showing white light |1.3.2e| | 1 |
| Offside Rear Body has a sharp edge caused by damage light lens broken |6.1.C.1| | 1 |
| Nearside Outer Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Macpherson strut upper support bearing is rough in operation |2.5.B.1b| | 1 |
| Offside Front Macpherson strut upper support bearing is rough in operation |2.5.B.1b| | 1 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |