| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 27 |
| Parking brake: efficiency below requirements |3.7.C.1b| | 24 |
| Brake pipe excessively corroded | 24 |
| Headlamp aim out of alignment | 20 |
| Brake hose excessively deteriorated | 11 |
| Windscreen wiper does not clear the windscreen effectively | 9 |
| Front brake disc in such a condition that it is seriously weakened | 7 |
| Rear parking brake recording little or no effort | 7 |
| Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 6 |
| Nearside Drag link end ball joint has excessive play |2.2.B.1f| | 6 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 6 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 6 |
| Anti-lock braking system warning lamp indicates an ABS fault | 6 |
| Offside Drag link end ball joint has excessive play |2.2.B.1f| | 5 |
| Offside Stop lamp not working |1.2.1b| | 5 |
| Battery insecure |1.9.1| | 5 |
| Registration plate issues | 5 |
| Parking brake lever has no reserve travel |3.1.6b| | 5 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 5 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 4 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 4 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 4 |
| Offside Rear Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 4 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
| Nearside Front brake disc excessively scored |3.5.1h| | 3 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 3 |
| Centre Exhaust system not adequately supported |7.1.1| | 3 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 3 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 3 |
| Parking brake: efficiency below requirements |3.7.B.7| | 3 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Windscreen wiper blade insecure | 3 |
| Offside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 2 |
| Centre Exhaust has part of the system excessively deteriorated |7.1.1a| | 2 |
| Nearside Front Direction indicator incorrect colour (4.4.3 (a)) | 2 |
| Offside Front Direction indicator incorrect colour (4.4.3 (a)) | 2 |
| Nearside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Brake hose damaged | 2 |
| Front Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Exhaust emissions carbon monoxide content at idle excessive |7.3.D.4| | 2 |
| Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 2 |
| Nearside Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill (7.1.1 (a) (i)) | 2 |
| Offside Seat belt anchorage prescribed area strength or continuity significantly reduced inner sill (7.1.1 (a) (i)) | 2 |
| Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 2 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i)) | 2 |
| Horn not working (7.7 (a)) | 2 |
| Front Exhaust has a major leak of exhaust gases (6.1.2 (a)) | 2 |
| Centre Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
| Centre Rear Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Upper Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Rear Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 2 |
| Nearside Rear brake disc contaminated by oil |3.5.1h| | 2 |
| Nearside Rear Stop lamp not working |1.2.1b| | 2 |
| Offside Rear Stop lamp not working |1.2.1b| | 2 |
| Centre Stop lamp not working |1.2.1b| | 2 |
| Nearside Stop lamp not working |1.2.1b| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 2 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 2 |
| Offside Front Wheel nut|s| missing |4.2.A.1e| | 2 |
| Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Stop lamp not working |1.2.1b| | 2 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 2 |
| Nearside Stop lamp|s| all not working |4.3.1 |a| |iii|| | 2 |
| Nearside Braking system leaking |3.6.A.1| | 1 |
| Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Panhard rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 1 |
| Front Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Offside Front Upper Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Parking brake lever inoperative doesnt work (1.1.6 (d)) | 1 |
| Rear brake binding | 1 |
| Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Upper Ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Central Upper Ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Front Battery insecure |1.9.1| | 1 |
| Nearside Front Headlamp aim so that beam "kick up" is not visible on the screen |1.8.B.1| | 1 |
| Offside Front Headlamp aim so that beam "kick up" is not visible on the screen BOTH HEADLAMPS OPAQUE RESULTING IN NO KICK UP OR PATTERN SHOWN |1.8.B.1| | 1 |
| Nearside Rear Fuel cap/sealing device missing LPG FUEL CAP MISSING |7.2.4a| | 1 |
| Horn not working |1.6.2a| | 1 |
| Nearside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Offside Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Windscreen washer not working | 1 |
| Battery insecure and likely to cause a short circuit |4.13 |a| |ii|| | 1 |
| Exhaust emissions likely to be affected by an exhaust leak |8.2.1.1 |b|| | 1 |
| Offside Rear Brake disc contaminated by oil |1.1.14 |b|| | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 1 |
| Brake lever has insufficient reserve travel |1.1.2 |a|| | 1 |
| Nearside Front Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Offside Front Headlamp has a product on the lens so that the light output is severely reduced |1.7.5a| | 1 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Rear Exhaust has a major leak of exhaust gases From box. (6.1.2 (a)) | 1 |
| Nearside Front Brake hose twisted |found during steering lock to lock check| |2.2.D.2b| | 1 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 1 |
| Rear Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
| Nearside Front Track rod end ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Offside Front Suspension arm ball joint excessively worn TOP AND BOTTOM |5.3.4 |a| |i|| | 1 |
| Service brake efficiency below requirements |1.2.2 |a| |i|| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Headlamp not working on main beam |1.7.5a| | 1 |
| Nearside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Front Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Nearside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Offside Front constant velocity joint gaiter insecurely mounted to its housing |2.5.C.1a| | 1 |
| Nearside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Front Brake hose twisted |3.6.B.4c| | 1 |
| Nearside Front Upper Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Front Lower Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Front Upper Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Offside Front Lower Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Horn not working (7.7 (a) (ii)) | 1 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 1 |
| Exhaust has a major leak of exhaust gases middle box (6.1.2 (a)) | 1 |
| Nearside Rear Suspension arm pin or bush excessively worn A-frame (5.3.4 (a) (i)) | 1 |
| Offside Rear Suspension arm pin or bush excessively worn A-frame (5.3.4 (a) (i)) | 1 |
| Offside Rear Brake disc contaminated hub seal leaking (1.1.14 (b)) | 1 |
| Nearside Rear Road wheel fixing missing (5.2.1 (a) (i)) | 1 |
| Offside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Shock absorbers has a serious fluid leak | 1 |
| Front Prop shaft joint excessively worn gearbox end |6.1.7 |c| |i|| | 1 |
| Front Prop shaft joint constant velocity boot no longer prevents the ingress of dirt gearbox end |6.1.7 |g| |ii|| | 1 |
| Nearside Rear Lower Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt boot split (6.1.7 (g) (ii)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt boot insecure (6.1.7 (g) (ii)) | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Front Upper Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Upper Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Track rod end ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Rear Upper Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Front Power steering ram|s| anchorage insecure |2.3.4a| | 1 |
| Offside Rear brake disc contaminated by oil |3.5.1h| | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced |7.1.1 |a| |i|| | 1 |
| Front brake disc excessively pitted |3.5.1h| | 1 |
| brake disc excessively scored |3.5.1h| | 1 |
| Offside Rear fog lamp not working |1.3.2b| | 1 |
| Offside Rear Tie bar/rod has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Rear Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Direction indicators not working |1.4.A.2c| | 1 |
| Emissions not tested |7.0| | 1 |
| Service brake is causing the vehicle to swerve to the nearside |3.7.C.2| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Offside Front Outer Prop shaft joint constant velocity boot no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Offside Front Drivers seat with a defective structure (6.2.5 (a) (i)) | 1 |
| Spare wheel insecure in carrier (6.1.5 (b) (i)) | 1 |
| Offside Obligatory mirror does not provide a view to the rear (3.3 (c)) | 1 |
| Nearside Front Upper Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Upper Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i)) | 1 |
| Nearside Drag link end ball joint has excessive play (2.1.3 (b) (i)) | 1 |
| Front Brake disc significantly and obviously worn both (1.1.14 (a) (i)) | 1 |
| Suspension arm pin or bush excessively worn rear axle upper a-frame bushes (5.3.4 (a) (i)) | 1 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Drivers seat with a defective structure (6.2.5 (a) (i)) | 1 |
| Nearside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b)) | 1 |
| Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i)) | 1 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 1 |
| Nearside Track rod end loose |2.2.B.1d| | 1 |
| Centre Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Nearside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Upper Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Front Lower Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 1 |
| Offside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Nearside Rear Anti-roll bar synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Offside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Obligatory mirror insecure |8.1.1| | 1 |
| Nearside Upper Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Rear Anti-roll bar has excessive play in a pin/bush |2.4.G.2| | 1 |
| Centre Drag link end ball pin shank loose |2.2.B.1c| | 1 |
| Nearside Drag link end ball pin shank loose |2.2.B.1c| | 1 |
| Offside Ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust system not adequately supported |7.1.1| | 1 |
| Nearside Front Brake pipe fouled by moving parts |3.6.B.2a| | 1 |
| Offside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Lower Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| All position lamps not working |1.1.A.3b| | 1 |
| Rear Upper Sub-frame synthetic bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 1 |
| Parking brake lever inoperative (1.1.6 (d)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 1 |
| Nearside Front Track rod end ball joint worn to the extent there is a serious risk of detachment (2.1.3 (b) (ii)) | 1 |
| Windscreen has damage | 1 |
| Offside Front brake caliper securing device missing |3.5.1j| | 1 |
| Drag link end ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Rear brake drum contaminated by oil |3.5.1h| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 1 |
| Steering damper deformed and unserviceable |2.2.C.1d| | 1 |
| Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement both rear D bushes |2.4.G.2| | 1 |
| Nearside Rear Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement eye bush in anti roll bar |2.4.G.2| | 1 |
| Offside Front brake disc excessively scored |3.5.1h| | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Nearside Rear Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Rear Suspension arm corroded and seriously weakened (5.3.3 (b) (i)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill / chassis (5.3.6 (a) (i)) | 1 |
| Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength arch (5.3.6 (a) (i)) | 1 |
| Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength arch (5.3.6 (a) (i)) | 1 |
| Brake fluid warning lamp inoperative when park brake applied |3.6.G.2| | 1 |
| Speedometer cannot be illuminated. |6.7.3| | 1 |
| Nearside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Rear Position lamp not working |4.2.1 |a|| | 1 |
| Nearside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Offside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
| Anti-lock braking system warning lamp is missing. |3.4.1a| | 1 |
| Brake fluid warning lamp inoperative |3.6.G.2| | 1 |
| Power steering pump leaking from a failed component |2.3.3b| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |
| Centre Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Power steering pipe|s| or hose|s| leaking |2.3.3b| | 1 |
| Nearside Side repeater not working |1.4.A.2c| | 1 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 1 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 1 |
| Nearside Front All position lamps not working |1.1.A.3b| | 1 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Upper Stop lamp not working |1.2.1b| | 1 |
| Exhaust has a major leak of exhaust gases front and middle (6.1.2 (a)) | 1 |
| Emissions not tested due to exhaust blow (8.2.1.2 (d)) | 1 |
| Central Stop lamp|s| not working |4.3.1 |a| |ii|| | 1 |
| Nearside Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Brake pipe excessively chafed |3.6.B.2c| | 1 |
| Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Offside Rear Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
| Nearside Front Upper Steering linkage ball joint has excessive play |2.1.3 |b| |i|| | 1 |
| Nearside Front Lower Steering linkage ball joint has excessive play |2.1.3 |b| |i|| | 1 |