| Most common failures | No# failures |
|---|
| Registration plate lamp issues | 199 |
| Windscreen wiper does not clear the windscreen effectively | 164 |
| Headlamp aim out of alignment | 114 |
| Anti-lock braking system warning lamp indicates an ABS fault | 82 |
| Parking brake: efficiency below requirements |3.7.B.7| | 72 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 58 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 49 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 48 |
| Parking brake lever has no reserve travel |3.1.6b| | 47 |
| Rear parking brake recording little or no effort | 47 |
| Brakes imbalanced across an axle | 35 |
| Brake pipe excessively corroded | 33 |
| Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 29 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 28 |
| Rear brake binding | 26 |
| Offside Front Position lamp not working (4.2.1 (a) (ii)) | 25 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 24 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 23 |
| Offside Front Front position lamp|s| not working |1.1.A.3b| | 22 |
| Nearside Front Front position lamp|s| not working |1.1.A.3b| | 20 |
| Offside Steering rack gaiter split |2.2.D.2d| | 20 |
| Offside Rear fog lamp not working |1.3.2b| | 19 |
| Registration plate issues | 19 |
| Battery insecure |1.9.1| | 18 |
| Offside Headlamp not working on main beam |1.7.5a| | 18 |
| Offside Front Steering rack gaiter split |2.2.D.2d| | 17 |
| Nearside Steering rack gaiter split |2.2.D.2d| | 17 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 17 |
| Nearside Stop lamp not working |1.2.1b| | 16 |
| Front brake disc in such a condition that it is seriously weakened | 16 |
| Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g)) | 16 |
| Offside Stop lamp not working |1.2.1b| | 15 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 15 |
| Nearside Front Headlamp not working on dipped beam |1.7.5a| | 14 |
| Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) | 14 |
| Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 13 |
| Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 13 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 12 |
| Nearside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 12 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 12 |
| Nearside Rear Service brake excessively binding (1.2.1 (f)) | 12 |
| Nearside Front Steering rack gaiter split |2.2.D.2d| | 11 |
| Offside Rear Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 11 |
| Rear brake disc in such a condition that it is seriously weakened | 11 |
| Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 10 |
| Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 10 |
| Electronic stability control warning lamp indicates a fault (7.12 (e)) | 10 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 10 |
| Nearside Front Position lamp not working |4.2.1 |a|| | 9 |
| Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 9 |
| Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 9 |
| Offside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 9 |
| Nearside Rear Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 9 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 9 |
| Parking brake efficiency less than 50% of the required value |1.4.2 |a| |ii|| | 8 |
| Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 8 |
| Offside Front Headlamp not working on dipped beam |1.7.5a| | 8 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 8 |
| Front brake excessively fluctuating | 8 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 8 |
| Offside Rear Service brake excessively binding (1.2.1 (f)) | 8 |
| Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 8 |
| Offside Front Track rod end ball joint has excessive play |2.2.B.1f| | 7 |
| Nearside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 7 |
| Supplementary restraint system warning lamp indicates a fault |7.1.6 |a|| | 7 |
| Offside Track rod end ball joint has excessive play |2.2.B.1f| | 7 |
| Offside Front Position lamp not working |4.2.1 |a|| | 7 |
| Offside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 7 |
| Offside Front Service brake excessively binding (1.2.1 (f)) | 7 |
| Front position lamp|s| not working |1.1.A.3b| | 6 |
| Rear fog lamp not working |1.3.2b| | 6 |
| Nearside Rear Parking brake inoperative on one side (1.4.1 (a)) | 6 |
| Offside Rear Parking brake inoperative on one side (1.4.1 (a)) | 6 |
| Brake lever has insufficient reserve travel (1.1.2 (a)) | 6 |
| Offside Parking brake inoperative on one side (1.4.1 (a)) | 6 |
| Stop lamp(s) all not working (4.3.1 (a) (iii)) | 6 |
| Centre Stop lamp not working |1.2.1b| | 5 |
| Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone `A` |8.3.1e| | 5 |
| Rear brake application uneven | 5 |
| Offside Front constant velocity joint gaiter insecure to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 5 |
| Electronic stability system warning lamp indicates a fault |3.4.1c| | 5 |
| Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i)) | 5 |
| Nearside Parking brake inoperative on one side (1.4.1 (a)) | 5 |
| Offside Headlamp not working on main beam (4.1.1 (a) (ii)) | 5 |
| Offside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 5 |
| Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 5 |
| Exhaust emissions exceed manufacturers specified limit (8.2.2.2 (a)) | 5 |
| Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Offside Side repeater not working |1.4.A.2c| | 4 |
| Nearside Headlamp not working on main beam |1.7.5a| | 4 |
| Fuel system component leaking |7.2.3| | 4 |
| Offside Front drive shaft support bearing excessively worn |2.5.C.2c| | 4 |
| Windscreen wiper blade insecure | 4 |
| Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 4 |
| Offside Front Direction indicator not working |1.4.A.2c| | 4 |
| Offside Headlamp aim beam image obviously incorrect |1.8.A.1b| | 4 |
| Engine MIL inoperative or indicates a malfunction |8.2.1.2 |h|| | 4 |
| Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Nearside Rear Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 4 |
| Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 4 |
| Nearside Outer Front constant velocity joint gaiter split |2.5.C.1a| | 4 |
| Offside Headlamp excessively deteriorated so that the light output is severely reduced |1.7.5a| | 4 |
| Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 4 |
| Offside Front constant velocity joint gaiter split |2.5.C.1a| | 4 |
| Nearside Front constant velocity joint gaiter split |2.5.C.1a| | 4 |
| Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 4 |
| Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Offside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 4 |
| Nearside Side repeater not working (4.4.1 (a) (ii)) | 4 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii)) | 4 |
| Nearside Front Service brake excessively binding (1.2.1 (f)) | 4 |
| Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 4 |
| Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 4 |
| Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii)) | 4 |
| Offside Rear fog lamp not working (4.5.1 (a) (ii)) | 4 |
| Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 4 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 4 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 3 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 3 |
| Offside Front Lower Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Front position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 3 |
| Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Offside Rear Stop lamp not working |1.2.1b| | 3 |
| Front Front position lamp|s| not working |1.1.A.3b| | 3 |
| Offside Front Headlamp not working on main beam |1.7.5a| | 3 |
| Nearside Parking brake inoperative on one side |1.4.1 |a|| | 3 |
| Nearside Headlamp not working on dipped beam |4.1.1 |a| |ii|| | 3 |
| Nearside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Offside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 3 |
| Offside Front Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Brake pedal spongy |3.3.B.1b| | 3 |
| Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt |6.1.7 |g| |ii|| | 3 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 3 |
| Driver`s airbag obviously defective |5.4.1| | 3 |
| Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt |2.1.3 |g| |ii|| | 3 |
| Engine MIL inoperative or indicates a malfunction |8.2.2.2 |g|| | 3 |
| Nearside Rear Parking brake inoperative on one side |1.4.1 |a|| | 3 |
| Offside Front wheel bearing rough when rotated |2.5.A.2| | 3 |
| Nearside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Nearside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Offside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc |2.5.C.1a| | 3 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 3 |
| Nearside Rear position lamp|s| not working |1.1.A.3b| | 3 |
| Rear Mechanical brake component has restricted free movement | 3 |
| Service brake: efficiency below requirements |3.7.B.7| | 3 |
| Anti-lock braking system warning lamp does not illuminate (1.6 (a)) | 3 |
| Offside Rear Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i)) | 3 |
| Offside Rear Position lamp not working (4.2.1 (a) (ii)) | 3 |
| Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 3 |
| Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt split (2.1.3 (g) (ii)) | 3 |
| Offside Front Suspension arm pin or bush excessively worn rear bush (5.3.4 (a) (i)) | 3 |
| Offside Front Headlamp not working on main beam (4.1.1 (a) (ii)) | 3 |
| Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 3 |
| Offside Front Direction indicator not working (4.4.1 (a) (ii)) | 3 |
| Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii)) | 3 |
| Nearside Headlamp not working on main beam (4.1.1 (a) (ii)) | 3 |
| Offside Rear Rear fog lamp not working (4.5.1 (a) (ii)) | 3 |
| Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 3 |