Most common failures | No# failures |
---|
Windscreen wiper does not clear the windscreen effectively | 20 |
Registration plate lamp issues | 13 |
Headlamp aim out of alignment | 11 |
Offside Rear fog lamp not working |1.3.2b| | 8 |
Brake pipe excessively corroded | 7 |
Brakes imbalanced across an axle | 7 |
Offside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 6 |
Nearside Front wheel bearing has excessive play |2.5.A.3c| | 5 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 5 |
Rear fog lamp not working |1.3.2b| | 5 |
Offside Rear fog lamp missing |1.3.2a| | 4 |
Offside Rear Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 4 |
Nearside Front position lamp|s| not working |1.1.A.3b| | 4 |
Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 3 |
Nearside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 3 |
Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement |2.4.B.2| | 3 |
Rear fog lamp missing |1.3.2a| | 3 |
Hazard warning lamps not flashing in phase, with ignition on |1.4.B.1f| | 3 |
Hazard warning lamps not flashing in phase, with ignition off |1.4.B.1f| | 3 |
Anti-lock braking system warning lamp indicates an ABS fault | 3 |
Offside Rear Shock absorber has a serious fluid leak |2.7.3| | 3 |
Offside Stop lamp not working |1.2.1b| | 3 |
Nearside Stop lamp not working |1.2.1b| | 2 |
Offside Rear Shock absorber has an excessively worn bush |2.7.4| | 2 |
Nearside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Front Anti-roll bar has excessive play in a ball joint |2.4.G.2| | 2 |
Offside Front Upper Suspension arm ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
Nearside Front Lower Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 2 |
Battery insecure |1.9.1| | 2 |
Offside Rear fog lamp insecure |1.3.2a| | 2 |
Offside Front front brake binding |3.7.B.1| | 2 |
Nearside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
Offside Rear Lower Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 2 |
Offside Front wheel bearing has excessive play |2.5.A.3c| | 2 |
Nearside Rear Leaf spring fractured |2.4.B.1a| | 2 |
Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 2 |
Rear fog lamp not working (4.5.1 (a) (ii)) | 2 |
Offside Front suspension has excessive play in a upper suspension ball joint |2.5.B.1a| | 2 |
Nearside Front brake disc excessively pitted |3.5.1h| | 2 |
Anti-lock braking system warning lamp does not illuminate |3.4.1b| | 2 |
Service brake: efficiency below requirements |3.7.C.1a| | 2 |
Brake hose excessively deteriorated | 2 |
Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
Nearside Rear Lower Shock absorber has an excessively worn bush |2.7.4| | 2 |
Brake pipe leaking |3.6.A.1| | 2 |
Parking brake: efficiency below requirements |3.7.C.1b| | 2 |
Hazard warning tell tale not working correctly |1.4.B.1e| | 2 |
Nearside Rear Shock absorber has an excessively worn bush |2.7.4| | 2 |
Rear parking brake recording little or no effort | 2 |
Exhaust has a major leak of exhaust gases |7.1.2| | 2 |
Offside Side repeater missing |1.4.A.2b| | 1 |
Nearside Side repeater not working |1.4.A.2c| | 1 |
Rear fog lamp tell tale not working |1.3.1b| | 1 |
Nearside Front Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Front Anti-roll bar linkage rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
Offside Rear Inner Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
Nearside Rear Inner Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength cross-member on offside (5.3.6 (a) (i)) | 1 |
Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i)) | 1 |
Supplementary restraint system warning lamp indicates a fault (7.1.6 (a)) | 1 |
Steering system excessively rough |2.2.D.1| | 1 |
Centre Seat belt locking mechanism does not secure or release |5.2.5a| | 1 |
Nearside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Offside Front Shock absorber has an excessively worn bush |2.7.4| | 1 |
Front brake disc in such a condition that it is seriously weakened | 1 |
Nearside front brake juddering severely |3.7.A.2b| | 1 |
Offside front brake juddering severely |3.7.A.2b| | 1 |
Offside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Nearside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Offside Rear Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Brake pedal spongy |3.3.B.1b| | 1 |
Parking brake: efficiency below requirements |3.7.B.7| | 1 |
Nearside Front Upper Suspension arm ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Offside Rear Leaf spring main leaf fractured |5.3.1 |b| |ii|| | 1 |
Offside Front Outer Anti-roll bar linkage ball joint excessively worn |5.3.4 |a| |i|| | 1 |
Offside Rear fog lamp not working |4.5.1 |a| |ii|| | 1 |
Nearside Rear Stop lamp|s| adversely affected by the operation of another lamp |4.3.3 |b|| | 1 |
Nearside Rear Stop lamp|s| showing white light to the rear |4.3.3 |a| |ii|| | 1 |
Battery leaking electrolyte |1.9.1| | 1 |
Offside Rear fog lamp does not face the rear |1.3.2a| | 1 |
Front passenger door cannot be opened from outside the vehicle |6.2.B.1b| | 1 |
Brake pedal anti-slip provision missing |3.3.A.1b| | 1 |
Nearside Front Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
Offside Front Upper Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
Offside Rear Leaf spring fractured |2.4.B.1a| | 1 |
Nearside Front Anti-roll bar linkage worn and seriously weakened |2.4.G.1| | 1 |
Nearside Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Rear Vehicle structure has a fracture which is likely to adversely affect braking or steering (6.1.1 (a) (ii)) | 1 |
Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i)) | 1 |
Rear Upper Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Cross member (6.1.1 (c) (i)) | 1 |
Rear Lower Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Cross member (6.1.1 (c) (i)) | 1 |
Fuel tank so insecure there is a risk of fire (6.1.3 (a) (ii)) | 1 |
Nearside Rear Position lamp not working (4.2.1 (a) (ii)) | 1 |
Nearside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
Nearside Rear Stop lamp adversely affected by the operation of another lamp |1.2.1f| | 1 |
Rear Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Offside Vehicle structure has excessive corrosion which adversely affects braking or steering in front of rear wheel |6.1.A.1| | 1 |
Windscreen has damage | 1 |
Offside Front brake disc excessively pitted |3.5.1h| | 1 |
Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear fog lamp emits a light other than red |1.3.2e| | 1 |
Offside Front Direction indicators not working |1.4.A.2c| | 1 |
Braking system leaking |3.6.A.1| | 1 |
Service brake: efficiency below requirements |3.7.B.7| | 1 |
Nearside Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Offside Leaf spring has excessive wear in a shackle pin and/or bush |2.4.B.2| | 1 |
Rear Brake pipe at imminent risk of failure or fracture Front to rear to flexi at end |1.1.11 |a|| | 1 |
Front brake disc excessively pitted |3.5.1h| | 1 |
Offside Front Seat belt retracting mechanism defective |5.2.5b| | 1 |
Offside Front Anti-roll bar linkage pin or bush excessively worn |5.3.4 |a| |i|| | 1 |
Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt |5.3.4 |b| |ii|| | 1 |
Nearside Rear Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
Offside Rear Leaf spring has excessive side play at eye |anchor| |2.4.B.4| | 1 |
Nearside Front Body has a sharp edge caused by damage |6.1.C.1| | 1 |
Vehicle structure excessively corroded within 30cm of towbar mounting |6.6.6| | 1 |
Rear brake application uneven | 1 |
Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i)) | 1 |
Windscreen washer not working | 1 |
Brake performance not tested (1.2.1 (g)) | 1 |
Nearside Front Shock absorbers has a serious fluid leak | 1 |
Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush as marked |2.4.B.2| | 1 |
Offside Rear Leaf spring has excessive side play at eye |shackle| |2.4.B.4| | 1 |
Front Exhaust has a major leak of exhaust gases |6.1.2 |a|| | 1 |
Nearside Parking brake inoperative on one side (1.4.1 (a)) | 1 |
Offside Headlamp not working on main beam |1.7.5a| | 1 |
Rear Rear fog lamp not working |1.3.2b| | 1 |
Rear fog lamp insecure |1.3.2a| | 1 |
Centre Stop lamp not working |1.2.1b| | 1 |
Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Front brake application uneven | 1 |
Horn not working |1.6.2a| | 1 |
Nearside Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
Brake performance not tested |3.7.A.1| | 1 |
Exhaust system not adequately supported |7.1.1| | 1 |
Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced above middle box (6.1.1 (c) (i)) | 1 |
Nearside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Rear brake binding | 1 |
Nearside Rear An item not tested |Manual| | 1 |
Offside Rear Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) | 1 |
Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c)) | 1 |
Exhaust emits an excessive level of metered smoke for a turbo charged engine |7.4.B.3b| | 1 |
Offside Rear reflector excessively damaged so that its function is impaired |1.5.1c| | 1 |
Rear fog lamp has less than 50% of the light sources illuminating |1.3.2b| | 1 |
Nearside Front Front wheel bearing rough when rotated |2.5.A.2| | 1 |
Nearside Front Front wheel bearing has excessive play |2.5.A.3c| | 1 |
Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Hazard warning switch faulty |1.4.B.1d| | 1 |
Nearside Rear Direction indicators not working |1.4.A.2c| | 1 |
Nearside Rear Direction indicator excessively damaged so that it is not visible from a reasonable distance |1.4.A.2e| | 1 |
Offside Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
Offside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Offside Rear Rear fog lamp missing |1.3.2a| | 1 |
Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
Nearside Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings |6.1.B.2| | 1 |
Registration plate issues | 1 |
Front Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
Mechanical brake component has restricted free movement | 1 |
Engine MIL inoperative or indicates a malfunction on dash. |8.2.1.2 |h|| | 1 |
Offside Front Service brake excessively binding |1.2.1 |f|| | 1 |
Offside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 1 |
Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
Nearside Cab steps in such a condition that it is likely to cause injury (6.2.8 (b)) | 1 |
Front Exhaust has a major leak of exhaust gases Flexi joint (6.1.2 (a)) | 1 |
Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Nearside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii)) | 1 |
Offside Rear position lamp|s| not working |1.1.A.3b| | 1 |
Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i)) | 1 |
Nearside Rear Shock absorbers damaged to the extent that it does not function (5.3.2 (b)) | 1 |
Offside Rear Shock absorbers damaged to the extent that it does not function (5.3.2 (b)) | 1 |
Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i)) | 1 |
Exhaust has a major leak of exhaust gases Rear silencer (6.1.2 (a)) | 1 |
Emissions not tested (8.2.2.2 (e)) | 1 |
Offside Rear Stop lamp not working |1.2.1b| | 1 |
Offside Rear Rear position lamp|s| not working |1.1.A.3b| | 1 |
Offside Rear Rear position lamp|s| adversely affected by the operation of another lamp |1.1.A.3f| | 1 |
Power steering pump drive system defective |2.3.6| | 1 |