| Most common failures | No# failures |
|---|
| Headlamp aim out of alignment | 15 |
| Parking brake: efficiency below requirements |3.7.B.7| | 10 |
| Rear parking brake recording little or no effort | 7 |
| Anti-lock braking system warning lamp indicates an ABS fault | 4 |
| Nearside Rear Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 4 |
| Offside Headlamp not working on dipped beam |1.7.5a| | 3 |
| Offside Rear fog lamp not working |1.3.2b| | 3 |
| Registration plate issues | 3 |
| Registration plate lamp issues | 3 |
| Nearside Stop lamp not working |1.2.1b| | 3 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 3 |
| Windscreen wiper does not clear the windscreen effectively | 3 |
| Offside Rear Upper Suspension arm has excessive play in a ball joint |2.4.G.2| | 3 |
| Offside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Front position lamp|s| not working |1.1.A.3b| | 2 |
| Fuel tank leaking |7.2.3| | 2 |
| Fuel system component leaking filler neck pipe to tank |7.2.3| | 2 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 2 |
| Nearside Front Direction indicators incorrect colour |1.4.A.2f| | 2 |
| Nearside Front coil spring fractured |2.4.C.1a| | 2 |
| Parking brake lever has no reserve travel |3.1.6b| | 2 |
| Nearside Rear Radius arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Offside Rear Radius arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Windscreen has damage | 2 |
| Offside Rear Trailing arm has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front Anti-roll bar linkage has excessive play in a pin/bush |2.4.G.2| | 2 |
| Nearside Steering arm has relative movement at its fixings |2.2.B.1h| | 2 |
| Rear brake binding | 2 |
| Brake pipe excessively corroded | 2 |
| Nearside Front Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 2 |
| Nearside Front suspension has excessive play in a lower suspension ball joint |2.5.B.1a| | 2 |
| Nearside Rear Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Nearside Front Track rod end ball joint has excessive play |2.2.B.1f| | 2 |
| Nearside Front Direction indicator incorrect colour |1.4.A.2f| | 2 |
| Centre Stop lamp not working |1.2.1b| | 2 |
| Brake hose excessively deteriorated | 2 |
| Parking brake efficiency below requirements (1.4.2 (a) (i)) | 2 |
| Nearside Front Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Nearside Headlamp not working on dipped beam |1.7.5a| | 1 |
| Offside Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Lower Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Front Lower Trailing arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Macpherson strut corroded and seriously weakened |2.4.G.1| | 1 |
| Rear wheel bearing has excessive play |2.6.2| | 1 |
| Nearside Steering pivot point has excessive play |2.2.B.1g| | 1 |
| Centre Rear Seat belt retracting mechanism defective |5.2.5b| | 1 |
| Nearside Rear Upper Suspension arm pin or bush excessively worn back arm (5.3.4 (a) (i)) | 1 |
| Oil leaking excessively from engine (8.4.1 (a) (i)) | 1 |
| Fuel tank leaking (6.1.3 (b) (i)) | 1 |
| Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i)) | 1 |
| Offside Rear wheel bearing has excessive play |2.6.2| | 1 |
| Offside Front Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Rear Radius arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Front Steering column shaft has excessive end float |2.1.3| | 1 |
| Front position lamp|s| not working front |1.1.A.3b| | 1 |
| Offside Rear Stop lamp not working |1.2.1b| | 1 |
| Nearside Front Drag link end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Nearside Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Offside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt drop link |2.4.G.2| | 1 |
| Nearside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Front Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Nearside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Offside Rear Wheel bolt|s| missing |4.2.A.1e| | 1 |
| Front Steering arm has relative movement at its fixings |2.2.B.1h| | 1 |
| Nearside Rear Trailing arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Trailing arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Offside Front Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Nearside Front Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Nearside Front Lower Anti-roll bar linkage has excessive play in a ball joint |2.4.G.2| | 1 |
| Exhaust has a major leak of exhaust gases |7.1.2| | 1 |
| Exhaust has part of the system excessively deteriorated |7.1.1a| | 1 |
| Offside Front Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Offside Front Direction indicator adversely affected by the operation of another lamp |1.4.A.2h| | 1 |
| Offside Front Direction indicator incomplete |1.5.A1b| | 1 |
| Offside Front position lamp|s| not working |1.1.A.3b| | 1 |
| Offside Outer Rear position lamp|s| excessively deteriorated so that it is not visible from a reasonable distance |1.1.A.3d| | 1 |
| Nearside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Front Headlamp not in good working order adversely affecting beam image |1.2.4a| | 1 |
| Offside Inner Front Track rod end ball joint has excessive play |2.2.B.1f| | 1 |
| Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c)) | 1 |
| Offside Rear coil spring fractured |2.4.C.1a| | 1 |
| Offside Rear passenger door cannot be opened from outside the vehicle |6.2.B.1c| | 1 |
| Windscreen wiper blade insecure | 1 |
| Offside Rear Parking brake inoperative on one side |1.4.1 |a|| | 1 |
| Offside Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.2.C.1c| | 1 |
| Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Fuel cap/sealing device missing |7.2.4a| | 1 |
| Offside Obligatory mirror seriously damaged, affecting the rear view |8.1.2a| | 1 |
| Offside Front Shock absorber has a serious fluid leak |2.7.3| | 1 |
| Nearside Rear Upper Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Rear Fuel pipe leaking |7.2.3| | 1 |
| Offside Rear Direction indicator incorrect colour |1.4.A.2f| | 1 |
| Nearside Headlamp aim headlamp not in good working order adversely affecting beam image |1.2.4b| | 1 |
| Supplementary Restraint System warning lamp indicates a fault |5.4.2| | 1 |
| Nearside Front Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Offside Rear Exhaust system not adequately supported |7.1.1| | 1 |
| Offside rear brake juddering severely |3.7.A.5b| | 1 |
| Front brake disc in such a condition that it is seriously weakened | 1 |
| Offside Front Tie bar/rod ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Lower Suspension arm has excessive play in a pin/bearing |2.4.G.2| | 1 |
| Centre Upper Stop lamp not working |1.2.1b| | 1 |
| Tie bar/rod has excessive play in a ball joint |2.4.G.2| | 1 |
| Suspension arm rubber bush bonding deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Rear coil spring incomplete |2.4.C.1a| | 1 |
| Nearside Front Headlamp aim beam image obviously incorrect |1.8.A.1b| | 1 |
| Nearside Front Ball joint has excessive play |2.2.B.1f| | 1 |
| Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i)) | 1 |
| Offside Front Steering linkage ball joint ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt Relay Arm |2.1.3 |g| |ii|| | 1 |
| Nearside Front Steering linkage ball joint has excessive play Relay Arm |2.1.3 |b| |i|| | 1 |
| Offside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii)) | 1 |
| Offside Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Suspension arm ball joint excessively worn rear arm (5.3.4 (a) (i)) | 1 |
| Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c)) | 1 |
| Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii)) | 1 |
| Offside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h)) | 1 |
| Nearside Front Position lamp not working (4.2.1 (a) (ii)) | 1 |
| Offside Rear Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Rear Suspension arm has excessive play in a ball joint |2.4.G.2| | 1 |
| Parking brake efficiency below requirements |1.4.2 |a| |i|| | 1 |
| Nearside Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Offside Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt |2.4.G.2| | 1 |
| Nearside Rear Lower Suspension arm has excessive play in a pin/bush |2.4.G.2| | 1 |
| Nearside Front Direction indicator not working |1.4.A.2c| | 1 |
| Nearside Rear Direction indicator not working |1.4.A.2c| | 1 |
| Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a)) | 1 |
| Offside Rear Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Nearside Front Lower Ball joint has excessive play |2.2.B.1f| | 1 |
| Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Radius arm rubber bush deteriorated resulting in excessive movement |2.4.G.2| | 1 |
| Offside Rear Rear fog lamp not working |1.3.2b| | 1 |